sMoosse
El Installation fasion
Page sta
Installing the Counterbalance
'= Refer to Setting up the circuits in the
Hydraulic section ofthis manual for intial
system set up
' Install the pear links to the ears on the hook
‘= Turn on the Top Drive power
Hook
Pear Link
1m Rotate the counterbalance mode valve from 2 Places
the RUN position to the RIG-UP postion
‘= When the cylinders reach the end of stroke,
slide the cylinder clevis over the pear link cylinder
and instal the cylinder clevis pin Clovis
"= After securing the counterbalance cylinder to 2 Places
the pear link, rotate the counterbalance
mode vaive to the RUN position
1 Agjust PCC clockwise to raise the prossure
attest port CB until the bail just begins to lit
‘ff ofthe block
'= Reduce the prossure slowly (25 psi) to allow
pressure to stablize cylinder
Clevis Pin
2 Places
Counterbalance
Cylinder
2 Places
(88 inch stroke)
Rig-up/Run/
‘Shutdown Valve
‘Shown in RIG-UP_
position (switch to RUN
after the counterbalance
is installeg)
Hydraulic
Manifold
jure 3-31. Installing the Counterbalance
3-34
@Y watiowat. onweLt vaRCO worwnov.com