Professional Documents
Culture Documents
Introduction of Project
Introduction of Project
Semi automatic PVC pipe bending machine needs 4 HP power for its
operation. The production process can be made as smooth by using
PLC controller. It is necessary to have an automatic cutter and air
compressor to operate this machine. By using this automatic
bending machine, we can make 8 bends in one minute. The size of
the bending machine is 2 meters length, 1.5 meters width and 2.5
meters height.
After cutting the pipe in a specified size, we should put pipe in to
machine for its bending process. The process of bending will be
taken place after heating the pipe by using a heater which is fixed
within the machine. After bending, we will get finished product from
the machine with sockets.
The machine can process about 480 bends in an hour. That is the
major specialization of the machine. The bending process can be
made with minimum production cost as it is done by sing fully
automatic PVC pipe bending machine.
by using this machine, we can bend wiring pipes in the sizes of 19
mm, 20 mm and 25 mm. At least, 19 mm and 20 mm wiring pipes
should be in 1.2 mm thickness and 25 mm pipe should be in 1.5 mm
thickness. It is better to have more thickness for its smooth and
feasible operation.
Project Report for PVC pipe bending unit
The project report for PVC pipe bending unit given in this section
studies. We provide investment expenditure to establish a PVC
wiring pipe bending unit, size of the unit, raw materials availability,
market potential and its profitability.
Investment expenditures
Building investment
Now we can look at its machine. Semi automatic PVC pipe bending
machine costs 6.5 lakh rupees. If you are planning to use fully
automatic pipe cutting machine, it costs RS 120,000. You can also
design and create a usual manual cutting machine within the costs of
RS 15,000 to RS 30,000. It is necessary to have an air compressor of
200 litre or 300 litre for this process and it costs about RS 30,000. so
total machinery investment will be = 8 lakh Indian rupee
Electrical and other investment
We can market our business through three different ways. You can
market this either wholesale or retail or even through distributors.
The main customers are electrical shops. In those shops you can
supply your products as in both wholesale and retail.
Whole sale process
You can supply it as wholesale for those shops that are purchasing it
in larger quantities. And you can also supply it as retile for those
electrical shops that are purchasing in smaller quantities. Here
distributors are the parties’ who are supply PVC pipes.
Distribution method
This category includes both PVC wiring pipe manufactures and PVC
wiring pipe distributors. For those groups, you can supply very huge
quantities of products. But in this case our profit margin might be
slightly low. Even though, it will be helpful to sell larger quantity of
products and to earn higher amount of money.
The easiest way to identify the distributors is to collect the list of
suppliers of PVC pipe in all electrical shops. After that you can
contact them directly to supply your products.
As it is using machine with less than 5 HP, it does not need any
licenses to operate. And the registration of GST is applicable to only
those units which have the turnover of higher than 40 lakhs rupees
revenue. So, GST will not be applicable to this business as it is not
included in that category. This unit also can be run as by taking
production by purchasing pipe from manufacturing companies in
piece rate. You can also market it in this way too.