Professional Documents
Culture Documents
Tolerances - SKF
Tolerances - SKF
Tolerances - SKF
Inner ring
d tΔdmp1) tVdsp1) tVdmp tΔBs tVBs tKia
Diameter series All Normal Modified3)
> ≤ U L 7, 8, 92) 0, 1 2, 3, 4 U L L
mm μm μm μm μm μm μm
– 2.5 0 –8 10 8 6 6 0 –40 – 12 10
2.5 10 0 –8 10 8 6 6 0 –120 –250 15 10
Feedback
10 18 0 –8 10 8 6 6 0 –120 –250 20 10
Outer ring
D tΔDmp tVDsp4) tVDmp4) tΔCs tKea
Open bearings Capped tVCs
Diameter series bearings5)
> ≤ U L 7, 8, 92) 0, 1 2, 3, 4 2, 3, 4
mm μm μm μm μm μm
2.5 18 0 –8 10 8 6 10 6 Identical to 15
18 30 0 –9 12 9 7 12 7 tΔBs and tVBs 15
1)Tolerances for tapered bores (taper
of an inner
30 50 0 1:12 → table
–11and taper 1:30
14→ table). 11 8 16 8 20
2) Diameter series 7 and 8 not covered by ISO 492. ring of the
3) same angular contact ball bearings.
Applies to inner rings and outer rings of bearings of matched bearing sets consisting of two or more bearings. Does not apply to universally matchable
4)Applies to bearings
50 80 prior to mounting
0 and after–13
removal of internal
16 or external 13
snap ring. 10 20 10 bearing as 25
5) Capped bearings are sealed or shielded bearings. the outer
80 120 0 –15 19 19 11 26 11 35
ring
120 150 0 –18 23 23 14 30 14 40
Feedback
315 400 0 –40 50 50 30 – 30 70
400 500 0 –45 56 56 34 – 34 80
500 630 0 –50 63 63 38 – 38 100