Professional Documents
Culture Documents
Suzuki QuickGuide Jan17-1
Suzuki QuickGuide Jan17-1
IMPORTANT NOTICE!
NOTE The function of the kill switch must be tested after
Do not touch or cut any existing wires or installation to verify that it stops the engine in the
electrically conducting components before you event of an emergency situation.
make sure the main voltage switch is OFF. Only
set the main voltage switch to ON after you are This is done by submerging the xFOB in water or
finished cutting and connecting wires. walking with the xFOB away from your boat until the
Make sure that all wires and conductive engine stops. The xHUB will then light red and give a
Fuse
connection points are free from corrosion before
connecting any wires. 1-3 A
Battery sound signal to indicate a man over board event.
10 - 32 VDC
Max continuous switch load: <5A
Min. Voltage: 7V
-Below this voltage the unit will turn off.
From existing
Close to Stop Kill Switch
5-pin IP67 Black/White
Connector
Switch position in inactive *The wire connections are the same for the
mode e.g. engine not running.
external kill switch and kill switch mounted in
Black/White the throttle casing.