Roll Nov seuss S
sgtreer tng
AMINATION, SEPTEMBER 2022
xe Title: Power Transmission and Distribution
Max. Marks: 15
westions, Missing data/ information if any, maybe suitably assumed
smver.
Attempt al
& mentioned in ¢
Question Marks | COs
the various:
substation,
atures and components of indoor and outdoor] 45 | egy
ip Of tigures, explain the follows vader layouts,
| ie i. -xplain the following ibution feeder layot leas
| 42 Ring maine |
| 2a [Derive the expression for the calculation of Industanes of a three phase| 5 | co1|
_ Symmetrically spaced transmission line
[peal the Inductsnce per km of a transposed double cireuit three-phase
ine as shown below. Each circuit of the line remains on its own side. The |
diameter of the conductor is 2.532 em.
2b a 6” ot 15 |COL
| &—9.0m——3 4.0m
| 6 oy
mr) @e
‘Determine the capacitance and the charging current per km when the threc-|
phase transmission line shown below is operating at 132 kV, 50 Hz, The
. diameter of the conductor is 0.8 em.
a : o—*
: 2
2s |
‘Draw the circuit diagram and phasor of a short transmission line. Also is
‘ns |con
30 | catoulate its ABCD parameter. soe
What doyou understand by,
4a | 1, Efficiency of transmission lines 15 |co2
2._Voltage regulation
Explain the Characteristic Impedance and Surge impedance with their) 15 | coy
4b
expressions. a
Find the A, B, C) D parameters of & three-phase, 100 km, 50 Hz transmission
5a |line with series impedance of (0.15 + j0.78) chm/kin and a shunt admittance) 1.8 |CO2
ofj5.010° obm/un, z
Determine the critical disruptive voltage and corona loss for a three-phase line|
‘sb Joperating at 110 kV which bas conductor of 1.25 em diameter arranged in a 18 |CO2)
3.05 m delta, Tuke air density of 1,07 and dielectric strength of air 21 kV/om.
tenceSO Oe ee eS CC.
‘otal no. of Pages 02
Total no sees Rate.
S* SEMESTER B.Tech, EE
END-SEMESTER EXAMINATION, NOV-DEC 2022
Time: 3.0 Hours Course Title: Electric Drives
ime: 3.
Max. Marks: 40
Note: - Attempt all questions. Missing data/ informari a ital med
& mentioned in the answer. formation ifany, maybe suitably assu
0. | Question Marks [Cos]
I —
[Qt [Attempt any two of the following,
JA drive has following parameters: J= 19 kg-m?,
Joad torque T= 0.05 N, Nem.
4 |cor
‘A motor is used to drive a hoist, Motor characteristics are given by,
00 — 0.2N, Nan
: V; T=-200-0.2N, N-m Fl eox
1(b) | Where, N is the speed in rpm.
When the hoist is loaded, the met torque T) 100, Nem and when it is
unloaded, net load torque Tj ~ -80, N-m. Obiain the equilibrium speeds for
‘operation in all four quadrants,
excited DC motor has an armature!
4 230 V, 960 rpm and 200 A separately 2
Been, f 0.02 (2, The motor is fed from a chopper which provides both’
braking operations. The source has a voltage of 230 V.