Professional Documents
Culture Documents
6020B Swing Hyd System
6020B Swing Hyd System
Page 1 of 2
Shutdown SIS
Previous Screen
Configuration: 6020B Hydraulic Mining Shovel DNR00001-UP (MACHINE) POWERED BY C32 Engine
Systems Operation
6020B Hydraulic Shovel Hydraulic System
Media Number -UENR0494-00 Publication Date -01/08/2015 Date Updated -20/11/2015
i06079114
When the swing joystick is moved in order to perform a SWING operation, the swing joystick sends an
electrical signal input to the machine ECM.
When the swing brake switch inside the cab is set to the UNLOCKED, the machine ECM sends an electrical
signal to solenoid valve for the swing parking brake. When the solenoid valve for the swing parking brake is
energized, pilot oil in line flows through the solenoid valve. Pilot oil then flows to the swing parking brake. This
pilot oil pressure releases the swing parking brake. The swing parking brakes are released before supply oil
flows to the swing motors.
Note: 10 seconds after all joystick and foot pedal signals stop, the swing break engages regardless of the
position of the swing brake switch inside the cab. If the swing brake switch is in the UNLOCKED position, and
the operator operates the joysticks or pedals, the swing break will immediately disengage.
The swing hydraulic system uses two proportional reducing valves to control the two swing control valves. The
control valves are located in the swing compartment.
The oil delivery for the swing hydraulic circuit is supplied by main pumps (P1) and (P2). When the swing
joystick is moved from the NEUTRAL position, swing brake solenoid is activated by the machine ECM. Swing
parking brake is then released. Motor rotary group starts to rotate. The swing motor is mounted on top of the
swing drive. The swing drive is installed on the upper structure. The swing drive reduces the motor speed by
two stages. The swing drive rotates the upper structure.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/productsearch/produ... 4/22/2018
6020B Hydraulic Mining Shovel DNR00001-UP (MACHINE) POWERED BY C32 Engine(SEBP7484 - 03) -... Page 2 of 2
The swing motors are a fixed displacement, bidirectional piston type hydraulic motor. The swing motors have a
pinion gear attached to the output shaft. The pinion gear engages with the internal gear teeth of the large
swing gear (swing bearing). The swing gear is held stationary to the undercarriage structure. When the swing
motors rotate, the upper structure rotates above the undercarriage structure.
• Swing motors
• Swing drives
Note: Refer to the appropriate sections in this manual for more information.
Copyright 1993 - 2018 Caterpillar Inc. Sun Apr 22 00:44:58 UTC+0400 2018
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/productsearch/produ... 4/22/2018