Professional Documents
Culture Documents
Vsol Gpon OLT Configuration Step by Step Guide 2023
Vsol Gpon OLT Configuration Step by Step Guide 2023
Vsol Gpon OLT Configuration Step by Step Guide 2023
Struggling to deploy your network with Vsol Gpon OLT, want to create a secured network,
and can’t find any helpful information on the internet. Don’t worry here I will guide you in
detail Vsol Gpon OLT configuration step by step. Vsol GPON OLT configuration little bit
difficult than Vsol EPON OLT. This article will configure vsol gpon olt using few steps with
VLAN. Let’s begin
VSOL GPON OLT has a fixed static IP address at AUX Port 192.168.8.200. For accessing this
IP you need to change your pc LAN IP using the same subnet. We change our pc IP to
192.168.8.201 and subnet mask 255.255.255.0.
Now we can access olt via Telnet (192.168.8.200) or web management https://192.168.8.200
Console Access:
Connect your PC to OLT Console port using Console cable. Console cable available at your
OLT Packet. You need to USB TO Serial converter to connect.
To get the CLI interface of OLT needs to use software like putty. And make sure to select
speed 115200
Let’s create vlan 200-208 and configure up link port G16 as a Trunk port
Username-admin
Password-Xpon@Olt9417#
gpon-olt> ena
gpon-olt(config)# exit
Successfully created vlan 200-208 and we use vlan 200 for olt remote management and
vlan 201 to 208 for PON Port.
gpon-olt(config-if-ge0/16)# exit
Vlan configured successfully with G16 Port we can check mac address using below
command
Assign IP address
We can access OLT from our local network using a local subnet IP address also we can
access olt any network using public IP address.
Let’s assign IP address to vlan 200 for olt remote access using below command
gpon-olt(interface-vlan-200)# exit
Telnet permission
Telnet is a protocol that provides a command-line interface for communicating remote
devices such as switch router servers etc.
By default telnet port is deny from the olt firewall, for access telnet need to allow telnet
permission
gpon-olt(config)# no login-access-list deny telnet 0.0.0.0 0.0.0.0
That’s all we already configured our olt uplink configurations. Lets configure PON (Passive
Optical Network)
gpon-olt(profile-onu:10)# commit
gpon-olt(profile-onu:10)# exit
Here successfully configured an ONU Profile Named gpononu and where onu id 10 and it’s
a 1 Ethernet port onu.
Step 4: Creating DBA Profile
DBA means Dynamic bandwidth allocation. This step we will create a DBA profile for ONU
bandwidth. Every GPON OLT like Huawei GPON OLT must to create DBA profile
gpon-olt(config)# show profile dba
using this command we can see a list of dba profiles, now we are creating a dba profile
which id will 10 and name dbagpon.
In this step, we will create a service profile where the profile id is 10 and the profile name
srv_pon1_vlan_201 (you can change the profile id and name as you wish) and tag VLAN to
the onu ethernet port.
PON port 1
now we can get internet from PON port1. if you have more ports of your olt using the
above guide you have to create a line and service profile for each pon port and bind the
profile to this pon port. That’s all. you have any queries plz contact us. I will definitely help
to yo configure your olt.
Troubleshooting: