Professional Documents
Culture Documents
Nov 23
Nov 23
Page 1 of 42
PGR001 Communication
Engine CAN One Wire Capability Enable One Wire Mode
Engine CAN Limp Home Mode idle speed
TSC1 Source Address SAE J1939 231
Eng Brake Source Address J1939 15
Trans Source Address J1939 3
ABS Source Address SAE J1939 11
Trans Retarder Srce Addr J1939 16
CC1 Source Address SAE J1939 23
CC2 Source Address SAE J1939 33
CC3 Source Address SAE J1939 49
EBC1 Source Address SAE J1939 49
ACC Source Address SAE J1939 42
Transmit EBC1 for AGS2 no EBC1, standard PTO message
AGS2 DM1 SPN Convert Method CPC2 style
ECAN UDS MCM Source Address 1
J1939 Initial Rx Timeout 15 s
enable XCP communication flag disabled
enable UDE communication flag disabled
J1939 Log Bus Off Fault disabled
J1939 TSC1 Engine Timeout 10
J1939 TSC1 Eng Ret timeout 15
J1939 EBC1 Timeout 30
J1939 EBC2 Timeout 30
J1939 EEC2 Timeout Timer Ticks 15
J1939 ERC1 Timeout Timer Ticks 30
J1939 ESS Timeout 30
J1939 ETC1 Timeout Timer Ticks 10
J1939 ETC2 Timeout Timer Ticks 30
J1939 ETC7 Timeout Timer Ticks 30
J1939 TCO1 Timeout Timer Ticks 15
J1939 ACC1 Timeout 30
J1939 CCVS Timeout Timer Ticks 30
J1939 DM1 Timeout Timer Ticks 300
J1587 output counter 25 counts
J1587 output interval time 200 ms
J1939 PTO Timeout Timer Ticks 30
J1939 Second Engine Address 2
J1708 trans timeout time 1.0 s
J1939 SPN1716 Mode allow cruise control operation
J1939 AGS2 Prio Flag Style use priority 7 (CPC2 style)
MCM Reprogram Mode Time 60000 ms
Oil Press on ECAN is Absolute disabled
J1939 CM1 Timout Timer Ticks 300
CM1 Fan Source Addr1 SAE J1939 25
CM1 DPF Source Addr SAE J1939 49
CM1 Fan Source Addr2 SAE J1939 49
J1939 RF Timeout Timer Ticks 300
J1939 SPN92 Mode Smoke Limitation not considered
VDC1 Source Address SAE J1939 62
J1939 VDC Timeout Timer Ticks 30
FUSO ISS Source Addr SAE J1939 1
J1939 Prop11 Message Timeout 30
J1939 TSC1 RPM Freeze Enable disable
PTO Source Address SAE J1939 23
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ6604... Page 2 of 42
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ6604... Page 3 of 42
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ6604... Page 4 of 42
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ6604... Page 5 of 42
PGR013 Inputs
Service Brake Switch Config Ccvs2
Trans Neutral Input Config not available
Park Brake Switch Config Ccvs2
CC ON OFF Switch Config Ccvs3
CC Set Cst Res Accel Sw Config Ccvs3
CC Pause Switch Config Ccvs3
2nd Axle Speed Switch Config hardwired
Clutch Switch Config Ccvs2
Engine Brake Switch Config info from J1939 (muxed)
3 18 DI Selection disable
Switchable Torque via 3 18 -3687.81 ft-lb
Switchable Torque via 4 13 -3687.81 ft-lb
1 01 DI Selection disable
1 02 DI Selection enable park brake interlock
4 18 DI Selection disable
4 13 DI Selection disable
1 10 DI Selection disable
3 01 AI Selection no sensor
4 17 DI Selection DPF regeneration switch
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ6604... Page 6 of 42
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ6604... Page 7 of 42
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ6604... Page 8 of 42
PGR023 Limiters II
Torque Factor Gear Dwn Protect 1.000
Gear Ratio Gear Down Protect 0.010
Torque Factor High Gear Power 1.000
Gear Ratio for High Gear Power 0.020
Torque Factor for Cruise Power 1.000
AL Engine Speed Threshold 50 rpm
AL Min Engine Speed Threshold 1200 rpm
AL Ramp up Rate 160.0 (1/min)/s
AL Min Engine Torque 100.0 %
AL Droop Parameter 3 Nm/rpm
ADM 1 Trans Prot 1 Veh Speed 0.00 mph
ADM 1 Trans Prot 2 Veh Speed 0.00 mph
ADM 1 Trans Prot Torque 3687.81 ft-lb
PasSmart Enable disabled
Fuel Economy Incentive Enable disabled
PS Pass Speed Increment 0.00 mph
PS Pass Speed Duration 0 min
PS Ramp Down Time 5s
PS Pass Speed Interval 8h
FEI Max Vehicle Speed Reward 0.00 mph
FEI Minimum Fuel Economy 7.0 mpg
FEI Conversion Factor 2.0 mph/mpg
FEI Use Trip Mileage based on filtered fuel economy
Progressive Shift Governor transient optimized for driveline disengaged
AL Conditions AL permanently active
PS Activate Lower TPS 5.0 %
PS Activate Upper TPS 95.0 %
PS Activation Cancel Timer 5.00 s
PS Activation Speed Timer 20.00 s
PS Cel Flash Time 60.00 s
FEI Filter Constant 0.020
FEI km per Liter Cap 47.0 mpg
FEI km per Liter Delta 6.6 mpg
AL Release Ramp 1.0 Nm/10ms
Progressive Shift Enable enabled
PS Veh Speed Hysteresis 3.23 mph
PS Low Gear 2 RPM Limit 2000 rpm
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ6604... Page 9 of 42
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 10 of 42
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 11 of 42
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 12 of 42
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 13 of 42
PGR041 Component ID
data request active flag complete Sequence
CI make ASCII character ae 0
CI make ASCII character ae 1
CI make ASCII character ae 2
CI make ASCII character ae 3
CI make ASCII character ae 4
CI model ASCII character ae 0
CI model ASCII character ae 1
CI model ASCII character ae 2
CI model ASCII character ae 3
CI model ASCII character ae 4
CI model ASCII character ae 5
CI model ASCII character ae 6
CI model ASCII character ae 7
CI unit ASCII character ae 0
CI unit ASCII character ae 1
CI unit ASCII character ae 2
CI unit ASCII character ae 3
CI unit ASCII character ae 4
CI unit ASCII character ae 5
CI unit ASCII character ae 6
CI unit ASCII character ae 7
CI unit ASCII character ae 8
CI unit ASCII character ae 9
Engine serial Number ae 0
Engine serial Number ae 1
Engine serial Number ae 2
Engine serial Number ae 3
Engine serial Number ae 4
Engine serial Number ae 5
Engine serial Number ae 6
Engine serial Number ae 7
Engine serial Number ae 8
Engine serial Number ae 9
PGR042 Top2
Top2 Auto Down Max Speed ae 0 1150 rpm
Top2 Auto Down Max Speed ae 1 1150 rpm
Top2 Auto Down Max Speed ae 2 1150 rpm
Top2 Auto Down Max Speed ae 3 1150 rpm
Top2 Auto Down Min Speed ae 0 1150 rpm
Top2 Auto Down Min Speed ae 1 1150 rpm
Top2 Auto Down Min Speed ae 2 1150 rpm
Top2 Auto Down Min Speed ae 3 1150 rpm
Top2 Auto Up Max Speed ae 0 1750 rpm
Top2 Auto Up Max Speed ae 1 1750 rpm
Top2 Auto Up Max Speed ae 2 1550 rpm
Top2 Auto Up Max Speed ae 3 1700 rpm
Top2 Auto Up Min Speed ae 0 1550 rpm
Top2 Auto Up Min Speed ae 1 1550 rpm
Top2 Auto Up Min Speed ae 2 1350 rpm
Top2 Auto Up Min Speed ae 3 1500 rpm
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 14 of 42
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 15 of 42
PGR044 SynGov
Gov16 Integ Gain2 Sync Gov 500.0 (Nm/100rpm)/s
Gov16 Integ Gain1 Sync Gov 120.0 (Nm/100rpm)/s
Gov16 Sync Gov Prop Gain 120.0 Nm/100rpm
Gov16 Threshold Off Eng Spd 100 rpm
Gov16 Threshold On Eng Spd 300 rpm
Speed Req Gradient Comp Time 0 ms
Mode Shift ECAN Status Enable disable
Gov16 Sync Gov Prop 2 Gain 120.0 Nm/100rpm
PGR052 Communication II
J1939 Prop24 Message Timeout 150
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 16 of 42
ACC041_EHM_Data_1
T Fuel Count Min 1 0 min
T Fuel Count Hour 1 1000 h
Engine Speed Count S_1 0s
Engine Speed Count_S_2 0s
Engine Speed Count_S_3 0s
Engine Speed Count_S_4 14 s
Engine Speed Count M_1 0 min
Engine Speed Count M_2 0 min
Engine Speed Count M_3 0 min
Engine Speed Count M_4 52 min
Engine Speed Count H_1 0h
Engine Speed Count H_2 0h
Engine Speed Count H_3 0h
Engine Speed Count H_4 35298 h
P Eng Oil Count S 0s
P Eng Oil Count M 0 min
P Eng Oil Count H 0h
ehm_p_charge_air_s_1 0s
ehm_p_charge_air_s_2 0s
ehm_p_charge_air_s_3 30 s
ehm_p_charge_air_min_1 0 min
ehm_p_charge_air_min_2 0 min
ehm_p_charge_air_min_3 43 min
ehm_p_charge_air_h_1 0h
ehm_p_charge_air_h_2 0h
ehm_p_charge_air_h_3 35288 h
ehm_t_charge_air_count_s_1 0s
ehm_t_charge_air_count_s_2 0s
ehm_t_charge_air_count_s_3 10 s
ehm_t_charge_air_count_s_4 0s
ehm_t_charge_air_count_min_1 0 min
ehm_t_charge_air_count_min_2 0 min
ehm_t_charge_air_count_min_3 25 min
ehm_t_charge_air_count_min_4 0 min
ehm_t_charge_air_count_h_1 0h
ehm_t_charge_air_count_h_2 0h
ehm_t_charge_air_count_h_3 35157 h
ehm_t_charge_air_count_h_4 0h
e2p_ehm_eng_time_count_s 16 s
e2p_ehm_eng_time_count_min 52 min
e2p_ehm_eng_time_count_h 35298 h
e2p_ehm_ois_status_s 0s
e2p_ehm_ois_status_min 0 min
e2p_ehm_ois_status_h 0h
ehm_basic.ehm_t_coolant_min_1 0 min
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 17 of 42
ehm_basic.ehm_t_coolant_min_2 0 min
ehm_basic.ehm_t_coolant_min_3 23 min
ehm_basic.ehm_t_coolant_h_1 0h
ehm_basic.ehm_t_coolant_h_2 0h
ehm_basic.ehm_t_coolant_h_3 35690 h
ACC042_EHM_Data_2
e2p_ehm_driv_cyc_count_ul 002080E0
e2p_ehm_ign_cyc_count_ul 000000FF
ACC043_EHM_Data_3
e2p_ehm_tc_speed_p_amb_reg_1 13.810 psi
e2p_ehm_tc_speed_p_amb_reg_2 14.386 psi
e2p_ehm_tc_speed_p_amb_reg_3 13.443 psi
e2p_ehm_tc_speed_p_amb_reg_4 14.422 psi
e2p_ehm_tc_speed_p_amb_reg_5 0.000 psi
e2p_ehm_tc_speed_p_amb_reg_6 13.815 psi
e2p_ehm_tc_speed_p_amb_reg_7 13.779 psi
e2p_ehm_tc_speed_p_amb_reg_8 13.384 psi
e2p_ehm_tc_speed_p_amb_reg_9 0.000 psi
e2p_ehm_tc_speed_p_amb_reg_10 13.878 psi
e2p_ehm_tc_speed_time_reg_1 137.6 s
e2p_ehm_tc_speed_time_reg_2 5797.2 s
e2p_ehm_tc_speed_time_reg_3 6.0 s
e2p_ehm_tc_speed_time_reg_4 5.4 s
e2p_ehm_tc_speed_time_reg_5 5.2 s
e2p_ehm_tc_speed_time_reg_6 5.8 s
e2p_ehm_tc_speed_time_reg_7 1854.6 s
e2p_ehm_tc_speed_time_reg_8 6.0 s
e2p_ehm_tc_speed_time_reg_9 2365.2 s
e2p_ehm_tc_speed_time_reg_10 1265.8 s
e2p_ehm_tc_speed_flag_reg_1 1-
e2p_ehm_tc_speed_flag_reg_2 1-
e2p_ehm_tc_speed_flag_reg_3 1-
e2p_ehm_tc_speed_flag_reg_4 1-
e2p_ehm_tc_speed_flag_reg_5 0-
e2p_ehm_tc_speed_flag_reg_6 1-
e2p_ehm_tc_speed_flag_reg_7 1-
e2p_ehm_tc_speed_flag_reg_8 1-
e2p_ehm_tc_speed_flag_reg_9 0-
e2p_ehm_tc_speed_flag_reg_10 1-
e2p_ehm_tc_speed_reg_count 9-
e2p_ehm_tc_speed_low_array_1_1 0.0 s
e2p_ehm_tc_speed_low_array_1_2 0.0 s
e2p_ehm_tc_speed_low_array_1_3 0.0 s
e2p_ehm_tc_speed_low_array_1_4 0.0 s
e2p_ehm_tc_speed_low_array_1_5 25.8 s
e2p_ehm_tc_speed_low_array_2_1 0.0 s
e2p_ehm_tc_speed_low_array_2_2 0.0 s
e2p_ehm_tc_speed_low_array_2_3 0.0 s
e2p_ehm_tc_speed_low_array_2_4 0.0 s
e2p_ehm_tc_speed_low_array_2_5 13107.0 s
e2p_ehm_tc_speed_high_array_1_1 0.0 s
e2p_ehm_tc_speed_high_array_1_2 0.0 s
e2p_ehm_tc_speed_high_array_1_3 0.0 s
e2p_ehm_tc_speed_high_array_1_4 0.0 s
e2p_ehm_tc_speed_high_array_1_5 13107.0 s
e2p_ehm_tc_speed_high_array_2_1 0.0 s
e2p_ehm_tc_speed_high_array_2_2 0.0 s
e2p_ehm_tc_speed_high_array_2_3 0.0 s
e2p_ehm_tc_speed_high_array_3_4 0.0 s
e2p_ehm_tc_speed_high_array_3_5 13107.0 s
ACC044_OP_Data_1
TMP_LOG_TABLE.tmp_ctr_1 0000065A
TMP_LOG_TABLE.tmp_ctr_2 0008823B
TMP_LOG_TABLE.tmp_ctr_3 0098C1AC
TMP_LOG_TABLE.tmp_ctr_4 B8D72D27
TMP_LOG_TABLE.tmp_ctr_5 05F87551
TMP_LOG_TABLE.tmp_ctr_6 00ADB9F1
TMP_LOG_TABLE.tmp_ctr_7 0043B20D
TMP_LOG_TABLE.tmp_ctr_8 0005CA61
TMP_LOG_TABLE.tmp_ctr_9 00000000
TMP_LOG_TABLE.tmp_ctr_10 00000000
TMP_LOG_TABLE.tmp_ctr_11 00000000
TMP_LOG_TABLE.tmp_ctr_12 00000000
TMP_LOG_TABLE.tmp_ctr_13 00000000
TMP_LOG_TABLE.tmp_ctr_14 00000000
TMP_LOG_TABLE.tmp_ctr_15 00000000
TMP_LOG_TABLE.tmp_ctr_16 00000000
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 18 of 42
TMP_LOG_TABLE.t_ecu_max 192.65 °F
e2p_fan_dpf_timer 433626 s
e2p_fan_oil_timer 0s
e2p_fan_pressure_timer 0s
e2p_fan_retarder_timer 0s
e2p_fan_intake_timer 109230 s
e2p_fan_coolant_timer 557270 s
e2p_fan_can_timer 25223310 s
e2p_fan_brake_timer 0s
e2p_csa_operating_hours 0h
e2p_csa_eng_hours_gh_clean_last 0h
e2p_epf_time_t_fuel_2_high 0.0 min
e2p_isp_l_oil_loss_qnty_s -3.38135 gal
e2p_isp_l_oil_qnty_val_b 0 Bit
eng_operating_hours 35298 h
eng_operating_minutes 51 min
eng_operating_seconds 1s
Index 1 E2P_SP_AIR_MASS_ADAPT 1.00000 -
Index 2 E2P_SP_AIR_MASS_ADAPT 1.00000 -
Index 3 E2P_SP_AIR_MASS_ADAPT 1.00000 -
e2p_csa_operating_minutes 0 min
e2p_csa_operating_seconds 0s
e2p_fan_sens_error_timer 6956 s
ACC045_OP_Data_2
Urban Mode Life Time 7803329.00 s
e2p_dpf_ash_last_clean_dist 51886.631 miles
dpf_diag_hcdu_run_time 0
e2p_dpf_hc_total_mass 25944.2305 g
e2p_dpf_regen_flag_b 0 Bit
e2p_dpf_total_dosing_time 5603560.00 s
e2p_dpf_total_itv_time 6834901.00 s
e2p_dpf_total_regen_time 0.00 s
e2p_dpf_soot_load_time 0.00 s
e2p_dpf_p_dp_time 0.00 s
e2p_dpf_man_trq_time 378795.31 s
e2p_dpf_time_regen_time 1166878.00 s
e2p_dpf_soot_load_cntr 0
e2p_dpf_p_dp_cntr 0
e2p_dpf_man_trq_cntr 232
e2p_dpf_time_regen_cntr 2196
e2p_dpf_fuel_delivered 0.000000 pound
e2p_dpf_dist_traveled 0.0000000 miles
e2p_dpf_time_since_last_regen 0.00 s
e2p_dpf_soot_load 0.00958332326 -
e2p_dpf_hc_total_mass_per_reg 0.0000 g
e2p_dpf_soot_over_timer 0.00 s
e2p_dpf_fuel_regen_time 120757.30 s
e2p_dpf_dist_regen_time 4608426.00 s
e2p_dpf_fuel_regen_cntr 56
e2p_dpf_dist_regen_cntr 2929
e2p_dpf_smoky_dist_travelled 0.0000000 miles
e2p_dpf_soot_over_status 0
e2p_dpf_smoky_engine 0-
e2p_dpf_sec_count 655350
e2p_dpf_hour_count 0.0
e2p_dpf_time_sec_count 27.02 s
e2p_dpf_time_since_last_purge 57738 min
e2p_dpf_soot_clean_ratio_s 1.00000 -
dpf_doser_leak_wait_time_us 0.00 s
e2p_dpf_ash_last_read_dist 0.000 miles
e2p_dpf_ash_3rd_slope 0.00 km/liter
e2p_dpf_ash_2nd_slope 0.00 km/liter
e2p_dpf_ash_1st_slope 0.00 km/liter
e2p_dpf_ash_number_reading 0
e2p_dpf_ash_last_read_vol 0.000 gal
e2p_dpf_current_regen_method 0
e2p_dpf_already_cal_dp_b Disabled
e2p_dpf_ash_vol_delta_p 0.000 gal
isp_t_doc_in_max 50.00 Degree
isp_t_doc_in_max_year 2021 year
isp_t_doc_in_max_day 23.0 day
isp_t_doc_in_max_month 6 month
isp_t_doc_in_max_hour 14 hr
isp_t_doc_in_max_minute 25 min
isp_t_doc_in_max_second 18.0 sec
isp_t_doc_out_max 50.00 Degree
isp_t_doc_out_max_year 2021 year
isp_t_doc_out_max_day 23.0 day
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 19 of 42
isp_t_doc_out_max_month 6 month
isp_t_doc_out_max_hour 14 hr
isp_t_doc_out_max_minute 25 min
isp_t_doc_out_max_second 18.0 sec
isp_t_dpf_out_max 50.00 Degree
isp_t_dpf_out_max_year 2021 year
isp_t_dpf_out_max_day 23.0 day
isp_t_dpf_out_max_month 6 month
isp_t_dpf_out_max_hour 14 hr
isp_t_dpf_out_max_minute 25 min
isp_t_dpf_out_max_second 18.0 sec
isp_p_dpf_in_max 2.167 psi
isp_p_dpf_in_max_year 2021 year
isp_p_dpf_in_max_day 23.0 day
isp_p_dpf_in_max_month 6 month
isp_p_dpf_in_max_hour 14 hr
isp_p_dpf_in_max_minute 40 min
isp_p_dpf_in_max_second 2.0 sec
isp_p_dpf_out_max 0.290 psi
isp_p_dpf_out_max_year 2021 year
isp_p_dpf_out_max_day 23.0 day
isp_p_dpf_out_max_month 6 month
isp_p_dpf_out_max_hour 14 hr
isp_p_dpf_out_max_minute 25 min
isp_p_dpf_out_max_second 18.0 sec
E2P_DPF_MAX_DELTA_P 0.000 psi
E2P_DPF_MAX_DP_DISTANCE 0.00 miles
E2P_DPF_PREV_PERCENT_FULL_ASH 0
E2P_DPF_P_FUEL_TIMER 0.00 s
e2p_dpf_ext_idle_time_accum 0.000 s
ACC046_OP_Data_3_01
e2p_pir_bits_mask 00000000
ACC046_OP_Data_3_02
e2p_epc_cor_fac 0040004000400040004000400040004000400040004000400040004000400040
ACC046_OP_Data_3_03
e2p_epc_init_b Off
ACC046_OP_Data_3_04
e2p_isc_time_cyl_int 89FE8702B804E8FC8802C5FA00000000
ACC046_OP_Data_3_05
e2p_esc_adap_cyl_1 0040004000400040004000400040004000400040004000400040004000400040004000400040004000
ACC046_OP_Data_3_06
e2p_esc_adap_cyl_2 0040004000400040004000400040004000400040004000400040004000400040004000400040004000
ACC046_OP_Data_3_07
e2p_esc_adap_cyl_3 0040004000400040004000400040004000400040004000400040004000400040004000400040004000
ACC046_OP_Data_3_08
e2p_esc_adap_cyl_4 0040004000400040004000400040004000400040004000400040004000400040004000400040004000
ACC046_OP_Data_3_09
e2p_esc_adap_cyl_5 0040004000400040004000400040004000400040004000400040004000400040004000400040004000
ACC046_OP_Data_3_0A
e2p_esc_adap_cyl_6 0040004000400040004000400040004000400040004000400040004000400040004000400040004000
ACC046_OP_Data_3_0B
e2p_pir_adapt_cyl_1_NOP0 0.000 ms
e2p_pir_adapt_cyl_1_NOP021 0.000 ms
e2p_pir_adapt_cyl_1_NOP042 0.000 ms
e2p_pir_adapt_cyl_1_NOP066 0.000 ms
ACC046_OP_Data_3_0C
e2p_pir_adapt_cyl_2_NOP0 0.000 ms
e2p_pir_adapt_cyl_2_NOP021 0.000 ms
e2p_pir_adapt_cyl_2_NOP042 0.000 ms
e2p_pir_adapt_cyl_2_NOP066 0.000 ms
ACC046_OP_Data_3_0D
e2p_pir_adapt_cyl_3_NOP0 0.000 ms
e2p_pir_adapt_cyl_3_NOP021 0.000 ms
e2p_pir_adapt_cyl_3_NOP042 0.000 ms
e2p_pir_adapt_cyl_3_NOP066 0.000 ms
ACC046_OP_Data_3_0E
e2p_pir_adapt_cyl_4_NOP0 0.000 ms
e2p_pir_adapt_cyl_4_NOP021 0.000 ms
e2p_pir_adapt_cyl_4_NOP042 0.000 ms
e2p_pir_adapt_cyl_4_NOP066 0.000 ms
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 20 of 42
ACC046_OP_Data_3_0F
e2p_pir_adapt_cyl_5_NOP0 0.000 ms
e2p_pir_adapt_cyl_5_NOP021 0.000 ms
e2p_pir_adapt_cyl_5_NOP042 0.000 ms
e2p_pir_adapt_cyl_5_NOP066 0.000 ms
ACC046_OP_Data_3_10
e2p_pir_adapt_cyl_6_NOP0 0.000 ms
e2p_pir_adapt_cyl_6_NOP021 0.000 ms
e2p_pir_adapt_cyl_6_NOP042 0.000 ms
e2p_pir_adapt_cyl_6_NOP066 0.000 ms
ACC046_OP_Data_3_11
e2p_pir_pre_time_update 89E2
ACC046_OP_Data_3_12
e2p_pir_dur_init_done 00
ACC046_OP_Data_3_13
e2p_pir_counter_cyl1 0000000000000000
ACC046_OP_Data_3_14
e2p_pir_counter_cyl2 0000000000000000
ACC046_OP_Data_3_15
e2p_pir_counter_cyl3 0000000000000000
ACC046_OP_Data_3_16
e2p_pir_counter_cyl4 0000000000000000
ACC046_OP_Data_3_17
e2p_pir_counter_cyl5 0000000000000000
ACC046_OP_Data_3_18
e2p_pir_counter_cyl6 0000000000000000
ACC046_OP_Data_3_19
e2p_esc_ecu_init_b Off
ACC046_OP_Data_3_1A
e2p_dpf_fps_high_timer 0s
ACC046_OP_Data_3_1B
e2p_dpf_p_fuel_high_timer 0.00 s
ACC046_OP_Data_3_1C
e2p_dpf_ash_last_clean_time 113301200 hours
ACC046_OP_Data_3_1D
e2p_dpf_ash_last_clean_fuel 1083476.62 pound
ACC049_1_DPF_Histogram
Maximum Continuous Idle Time Current Regen 0s
Idle Time Current Regen 0s
Time Regen Flag Off in Zones 1,2,3 Current Regen 0s
Dosing Time Current Regen 0s
Average Fuel Pressure Not Dosing Current Regen 0.00 psi
Average Fuel Pressure While Dosing Current Regen 0.00 psi
Zone 1,2,3 Operation Time Current Regen 0s
Duration Dosing Interrupted For Low Vehicle Speed Current Regen 0s
Duration Dosing Interrupted For Low DOC Inlet Temp Current Regen 0s
Time Inhibit Switch Interrupted Dosing Current Regen 0s
Time Other Interrupted Dosing Current Regen 0s
Regeneration Fuel Used Current Regen 0g
Min Compensation Fuel Pressure While Dosing Current Regen 145.04 psi
Max Compensation Fuel Pressure While Dosing Current Regen 0.00 psi
Zone 1,2,3 Operation Time Last Completed Regen 0s
Idle Time Last Complete Regen 0s
Time Regen Flag Off in Zones 1,2,3 Last Completed Regen 0s
Regeneration Fuel Used Last Completed Regen 0g
Dosing Time Last Complete Regen 0s
Maximum Continuous Idle Time Last Completed Regen 0s
Max Compensation Fuel Pressure While Dosing Last Completed Regen 0.00 psi
Min Compensation Fuel Pressure While Dosing Last Completed Regen 145.04 psi
Duration Dosing Interrupted For Low DOC Inlet Temp Last Completed Regen 0s
Time Inhibit Switch Interrupted Dosing Last Completed Regen 0s
Time Other Interrupted Dosing Last Completed Regen 0s
Average Fuel Pressure While Dosing Last Completed Regen 0.00 psi
Average Fuel Pressure Not Dosing Last Completed Regen 0.00 psi
Maximum Zone Current Regen 2
Maximum Zone Last Completed Regen 5
Maximum DOC Outlet Temperature Current Regen 32 °F
Maximum DOC Outlet Temperature Last Completed Regen 32 °F
Maximum DPF Outlet Temperature Current Regen 32 °F
Maximum DPF Outlet Temperature Last Completed Regen 32 °F
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 21 of 42
ACC049_DPF_Histogram_01
E2P_DPF_NORM_H1_DOC_TI_BIN0 0
E2P_DPF_NORM_H1_DOC_TI_BIN1 0
E2P_DPF_NORM_H1_DOC_TI_BIN2 0
E2P_DPF_NORM_H1_DOC_TI_BIN3 0
E2P_DPF_NORM_H1_DOC_TI_BIN4 0
E2P_DPF_NORM_H1_DOC_TI_BIN5 0
E2P_DPF_NORM_H1_DOC_TI_BIN6 0
E2P_DPF_NORM_H1_DOC_TI_BIN7 0
E2P_DPF_NORM_H1_DOC_TI_BIN8 0
E2P_DPF_NORM_H1_DOC_TI_BIN9 0
ACC049_DPF_Histogram_02
E2P_DPF_NORM_H2_DOC_TI_BIN0 0
E2P_DPF_NORM_H2_DOC_TI_BIN1 0
E2P_DPF_NORM_H2_DOC_TI_BIN2 0
E2P_DPF_NORM_H2_DOC_TI_BIN3 0
E2P_DPF_NORM_H2_DOC_TI_BIN4 0
E2P_DPF_NORM_H2_DOC_TI_BIN5 0
E2P_DPF_NORM_H2_DOC_TI_BIN6 0
E2P_DPF_NORM_H2_DOC_TI_BIN7 0
E2P_DPF_NORM_H2_DOC_TI_BIN8 0
E2P_DPF_NORM_H2_DOC_TI_BIN9 0
ACC049_DPF_Histogram_03
DOC_TI, Thermal Management Conditions, Current Regen BIN0 0
DOC_TI, Thermal Management Conditions, Current Regen BIN1 0
DOC_TI, Thermal Management Conditions, Current Regen BIN2 0
DOC_TI, Thermal Management Conditions, Current Regen BIN3 0
DOC_TI, Thermal Management Conditions, Current Regen BIN4 0
DOC_TI, Thermal Management Conditions, Current Regen BIN5 0
DOC_TI, Thermal Management Conditions, Current Regen BIN6 0
DOC_TI, Thermal Management Conditions, Current Regen BIN7 0
DOC_TI, Thermal Management Conditions, Current Regen BIN8 0
DOC_TI, Thermal Management Conditions, Current Regen BIN9 0
ACC049_DPF_Histogram_04
DOC_TI, Thermal Management Conditions, Last Completed Regen BIN0 0
DOC_TI, Thermal Management Conditions, Last Completed Regen BIN1 0
DOC_TI, Thermal Management Conditions, Last Completed Regen BIN2 0
DOC_TI, Thermal Management Conditions, Last Completed Regen BIN3 0
DOC_TI, Thermal Management Conditions, Last Completed Regen BIN4 0
DOC_TI, Thermal Management Conditions, Last Completed Regen BIN5 0
DOC_TI, Thermal Management Conditions, Last Completed Regen BIN6 0
DOC_TI, Thermal Management Conditions, Last Completed Regen BIN7 0
DOC_TI, Thermal Management Conditions, Last Completed Regen BIN8 0
DOC_TI, Thermal Management Conditions, Last Completed Regen BIN9 0
ACC049_DPF_Histogram_05
Year of Regen Start, Current Regen 2038 year
Month of Regen Start, Current Regen 4 month
[!]Day of Regen Start, Current Regen DiagManager: 06058:No matching
day
interval was found
Hour of Regen Start, Current Regen 16 hr
Minute of Regen Start, Current Regen 53 min
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 22 of 42
ACC049_DPF_Histogram_06
DOC_TO, Current Regen BIN0 0
DOC_TO, Current Regen BIN1 0
DOC_TO, Current Regen BIN2 0
DOC_TO, Current Regen BIN3 0
DOC_TO, Current Regen BIN4 0
DOC_TO, Current Regen BIN5 0
DOC_TO, Current Regen BIN6 0
DOC_TO, Current Regen BIN7 0
DOC_TO, Current Regen BIN8 0
DOC_TO, Current Regen BIN9 0
ACC049_DPF_Histogram_07
DOC_TO, Last Complete Regen BIN0 0
DOC_TO, Last Complete Regen BIN1 0
DOC_TO, Last Complete Regen BIN2 0
DOC_TO, Last Complete Regen BIN3 0
DOC_TO, Last Complete Regen BIN4 0
DOC_TO, Last Complete Regen BIN5 0
DOC_TO, Last Complete Regen BIN6 0
DOC_TO, Last Complete Regen BIN7 0
DOC_TO, Last Complete Regen BIN8 0
DOC_TO, Last Complete Regen BIN9 0
ACC049_DPF_Histogram_08
DPF_TO, Current Regen BIN0 0
DPF_TO, Current Regen BIN1 0
DPF_TO, Current Regen BIN2 0
DPF_TO, Current Regen BIN3 0
DPF_TO, Current Regen BIN4 0
DPF_TO, Current Regen BIN5 0
DPF_TO, Current Regen BIN6 0
DPF_TO, Current Regen BIN7 0
DPF_TO, Current Regen BIN8 0
DPF_TO, Current Regen BIN9 0
ACC049_DPF_Histogram_09
DPF_TO, Last Complete Regen BIN0 0
DPF_TO, Last Complete Regen BIN1 0
DPF_TO, Last Complete Regen BIN2 0
DPF_TO, Last Complete Regen BIN3 0
DPF_TO, Last Complete Regen BIN4 0
DPF_TO, Last Complete Regen BIN5 0
DPF_TO, Last Complete Regen BIN6 0
DPF_TO, Last Complete Regen BIN7 0
DPF_TO, Last Complete Regen BIN8 0
DPF_TO, Last Complete Regen BIN9 0
ACC049_DPF_Histogram_0A
Year of Regen Start, Last Complete Regen 2036 year
Month of Regen Start, Last Complete Regen 6 month
[!]Day of Regen Start, Last Complete Regen DiagManager: 06058:No
day
matching interval was found
Hour of Regen Start, Last Complete Regen 14 hr
Minute of Regen Start, Last Complete Regen 21 min
[!]Second of Regen Start, Last Complete Regen DiagManager: 06058:No
sec
matching interval was found
ACC050_TRAP
unknown_bit_0 On
reserved_ bit_1 On
reserved_ bit_2 On
reserved_ bit_3 Off
AD-Ref_Vol_fail_bit_4 On
reserved_ bit_5 On
reserved_ bit_6 On
reserved_ bit_7 On
ECC_ bit_8 On
L3_Monitoring_bit_9 On
Trap_X3_bit_10 On
reserved_ bit_11 On
reserved_ bit_12 On
reserved_ bit_13 On
reserved_ bit_14 On
reserved_ bit_15 On
HDRST_ bit_16 On
ADConverter_fail_bit_17 On
µC_WDT_bit_18 On
PCP_µCbit_19 Off
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 23 of 42
Trap_X2_ bit_20 On
ECC_2Bit_bit_21 On
Prog_flow_bit_22 On
reserved_ bit_23 On
reserved_ bit_24 On
reserved_ bit_25 On
WDA_CY320_bit_26 On
SWRST_bit_27 On
Trap_X1_bit_28 On
NMI_ bit_29 On
RAM-TEST_bit_30 On
reserved_ bit_31 On
Current Firmware SW Version Release Number 0
Current Firmware SW Version Subrelease Number 1
Current Firmware SW Version Patch Number 0
Current Firmware Prototype SW Release Number 63
ACC051_Diag
e2p_mu_fault_status 0
PGR001_2_PropValve
PWM12 Configuration not parameterized
PWM13 Configuration Jake-Brake-1
SW1 Configuration not parameterized
SW2 Configuration not parameterized
SW3 Configuration turbo control
SW4 Configuration test (actuator turbo compound bypass)
SW5 Configuration not parameterized
SW6 Configuration not parameterized
SW7 Configuration not parameterized
SW8 Configuration fuel cut off valva
PGR001_PropValve
PWM1 Configuration not parameterized
PWM2 Configuration not parameterized
PWM3 Configuration not parameterized
PWM4 Configuration not parameterized
PWM5 Configuration not parameterized
PWM6 Configuration fan 2
PWM7 Configuration Jake-Brake-2
PWM8 Configuration not parameterized
PWM9 Configuration not parameterized
PWM10 Configuration not parameterized
PGR002_1_SensorConfig
Ambient Air Temperature Not Installed
Ambient Air Humidity Not Installed
Charge Air Temperature (Post) Not Installed
EGR Temperature Not Installed
Rail Pressure Not Installed
Oil Pressure Sensor Type absolute Sensor
Turbocharger Inlet Pressure Not Activated
Fuel Filter Water Level Not Activated
PGR002_SensorConfig
CAC Outlet Pressure Not Installed
Doser Pressure Inlet Not Installed
Charge Air Temperature Installed
Coolant Temperature In Not Installed
Fuel Temperature Installed
Oil Temperature Installed
Oil Pressure Installed
Catalyst Inlet Temp Not Installed
Catalyst Outlet Temp Not Installed
PGR003_CANConfig
MCM accepts CPC2 commands On
one wire capability CAN On
Baudrate 250/500 KBaud (MARCI CAN) 250 KBaud
CAN 3 active Off
e2p_xcp_ccp_enable_b Off
Strict Vehicle Check Enable Off
e2p_scl_can_limp_home Off
PGR004_1_EngineConfig
Trans Limp Home Mode Manual
Starter Type Control Starter activated via Hardwire
PGR004_2_EngineConfig
Engine Model Number 6067HG6E*
PGR004_3_EngineConfig
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 24 of 42
PGR004_4_EngineConfig
Oil Separator Enable Not Active
PGR004_5_EngineConfig
Anti Idle Enable Not Active
PGR004_EngineConfig
Engine Serial Number 06R0994779
PGR005_EOL
Index 1 of speed characteristic point of EOL map 2000.0 rpm
Index 2 of speed characteristic point of EOL map 2000.0 rpm
Index 3 of speed characteristic point of EOL map 2000.0 rpm
Index 4 of speed characteristic point of EOL map 2100.0 rpm
Index 1 of correction factor of EOL map 1.0000
Index 2 of correction factor of EOL map 1.0000
Index 3 of correction factor of EOL map 1.0000
Index 4 of correction factor of EOL map 1.0000
PGR006_FanConfig
Fan Type Single Speed Fan - 2 outputs
Fan Coolant Temp Stage 1 208 °F
Fan Air Temp Stage 1 176 °F
Fan Coolant Temp Stage 2 208 °F
Fan Air Temp Stage 2 176 °F
Fan Air Temp Stage 1 Eng Brake 176 °F
Fan Air Temp Stage 2 Eng Brake 176 °F
Type 2 Fan Ratio 0.000
Type 2 Fan PWM max 100.00 %
Type 2 PWM Freq 5.0 ms
Type 2 Maximum Fan Slip 0.0 W
Type 2 Fan Pulses Per Rev 0
Fan Temp Offset Ambient Temperature 0
Fan Temp Offset Ambient Temperature (Brake Mode) 0
Fan Low Speed Ratio 0.50 %
Fan High Speed Ratio 1.20 %
Fan Trq for Trq Loss Y1 0.0
Fan Trq for Trq Loss Y2 15.0
Fan Trq for Trq Loss Y3 33.0
Fan Trq for Trq Loss Y4 60.0
Fan Trq for Trq Loss Y5 86.0
Fan Trq for Trq Loss Y6 128.0
Fan Trq for Trq Loss Y7 165.0
Fan Trq for Trq Loss Y8 254.0
Fan Speed for Trq Loss X1 0.0
Fan Speed for Trq Loss X2 2100.0
Fan Speed for Trq Loss X3 2100.0
Fan Speed for Trq Loss X4 2100.0
Fan Speed for Trq Loss X5 2100.0
Fan Speed for Trq Loss X6 2200.0
Fan Speed for Trq Loss X7 2500.0
Fan Speed for Trq Loss X8 3100.0
Dyn FAN Brake Temp Threshold 32 °F
Dyn FAN Brake On Time 10 s
Dyn FAN Brake Hold Time 20 s
Dyn FAN Brake Enable Disabled
Temp Threshold in Brake Mode Fan 1 208 °F
Temp Threshold in Brake Mode Fan 2 208 °F
e2p_t_cool_in_on_fan1 32 °F
PGR007_1_DPFConfig
Initiate DPF Regen electronic
DPF zone 2 Time Trigger 0 min
DPF zone 2 Dist Trigger 0.0 miles
DPF zone 2 Fuel Trigger 0 pound
DPF HEST Max Speed Threshold 0.0 mph
DPF HEST Lamp Min Time 20 s
DPF HEST Lamp Temp Off 968.00 °F
DPF HEST Lamp Temp On 977.00 °F
DPF HEST Lamp Speed Hyst 1.2 mph
DPF Manual Regen Only Enable Disabled
DPF Shutdown Enable Disabled
DPF Diag Slow On Enable Disabled
DPF zone 5 Time Trigger 1140 min
DPF zone 5 Dist Trigger 799.7 miles
DPF zone 5 Fuel Trigger 1107 pound
EPA HIR Min Dist 14291.5 miles
EPA HIR Min Fuel 29542 pound
EPA HIR Min Time 60000 min
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 25 of 42
PGR007_DPFConfig
DPF Exhaust Pipe Volume (from Doser to DOC inlet) 0.007000 m^3
DPF Time Interval Regen Disabled
DPF zone 1 Time Trigger 0 min
DPF zone 3 Time Trigger 0 min
DPF zone 4 Time Trigger 0 min
DPF Distance Interval Regen Disabled
DPF zone 1 Dist Trigger 0.0 miles
DPF zone 3 Dist Trigger 0.0 miles
DPF zone 4 Dist Trigger 0.0 miles
DPF Fuel Interval Regen Disabled
DPF zone 1 Fuel Trigger 0 pound
DPF zone 3 Fuel Trigger 0 pound
DPF zone 4 Fuel Trigger 0 pound
Park Brake On Dosing Inhibit Disabled
PGR008_ColdStartConfig
Cold Start Type Disabled
Cold Start Heater Flange Disabled
PGR010_OtherFactors
Start enrichment factor 0.00000
Torque Temperature Compensation Bit 0.00
EGR System Active Bit Disabled
Turbo Type 0
Idle Smooth Cntl Reset Not Active
TDC Correction 0.00 °Crank
sp_air_mass_c0_select_uc 0-
PGR011_E_TRIM_Cyl_1_CurrentDurationTrim
Cyl_1_TrimPoint_1 -0.031 msec
Cyl_1_TrimPoint_2 -0.031 msec
Cyl_1_TrimPoint_3 -0.059 msec
Cyl_1_TrimPoint_4 -0.052 msec
Cyl_1_TrimPoint_5 0.003 msec
Cyl_1_TrimPoint_6 0.003 msec
Cyl_1_TrimPoint_7 0.006 msec
Cyl_1_TrimPoint_8 0.000 msec
Cyl_1_TrimPoint_9 0.000 msec
Cyl_1_TrimPoint_10 0.000 msec
PGR012_E_TRIM_Cyl_2_CurrentDurationTrim
Cyl_2_TrimPoint_1 0.045 msec
Cyl_2_TrimPoint_2 0.003 msec
Cyl_2_TrimPoint_3 0.024 msec
Cyl_2_TrimPoint_4 0.031 msec
Cyl_2_TrimPoint_5 0.003 msec
Cyl_2_TrimPoint_6 0.003 msec
Cyl_2_TrimPoint_7 0.006 msec
Cyl_2_TrimPoint_8 0.000 msec
Cyl_2_TrimPoint_9 0.000 msec
Cyl_2_TrimPoint_10 0.000 msec
PGR013_E_TRIM_Cyl_3_CurrentDurationTrim
Cyl_3_TrimPoint_1 -0.038 msec
Cyl_3_TrimPoint_2 -0.052 msec
Cyl_3_TrimPoint_3 -0.045 msec
Cyl_3_TrimPoint_4 -0.024 msec
Cyl_3_TrimPoint_5 0.003 msec
Cyl_3_TrimPoint_6 0.003 msec
Cyl_3_TrimPoint_7 0.006 msec
Cyl_3_TrimPoint_8 0.000 msec
Cyl_3_TrimPoint_9 0.000 msec
Cyl_3_TrimPoint_10 0.000 msec
PGR014_E_TRIM_Cyl_4_CurrentDurationTrim
Cyl_4_TrimPoint_1 0.031 msec
Cyl_4_TrimPoint_2 -0.010 msec
Cyl_4_TrimPoint_3 0.010 msec
Cyl_4_TrimPoint_4 0.017 msec
Cyl_4_TrimPoint_5 0.003 msec
Cyl_4_TrimPoint_6 0.003 msec
Cyl_4_TrimPoint_7 0.006 msec
Cyl_4_TrimPoint_8 0.000 msec
Cyl_4_TrimPoint_9 0.000 msec
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 26 of 42
Cyl_ 0.000 msec
PGR015_E_TRIM_Cyl_5_CurrentDurationTrim
Cyl_5_TrimPoint_1 -0.031 msec
Cyl_5_TrimPoint_2 -0.038 msec
Cyl_5_TrimPoint_3 -0.038 msec
Cyl_5_TrimPoint_4 -0.038 msec
Cyl_5_TrimPoint_5 0.003 msec
Cyl_5_TrimPoint_6 0.003 msec
Cyl_5_TrimPoint_7 0.006 msec
Cyl_5_TrimPoint_8 0.000 msec
Cyl_5_TrimPoint_9 0.000 msec
Cyl_5_TrimPoint_10 0.000 msec
PGR016_E_TRIM_Cyl_6_CurrentDurationTrim
Cyl_6_TrimPoint_1 0.010 msec
Cyl_6_TrimPoint_2 -0.010 msec
Cyl_6_TrimPoint_3 -0.003 msec
Cyl_6_TrimPoint_4 0.017 msec
Cyl_6_TrimPoint_5 0.003 msec
Cyl_6_TrimPoint_6 0.003 msec
Cyl_6_TrimPoint_7 0.006 msec
Cyl_6_TrimPoint_8 0.000 msec
Cyl_6_TrimPoint_9 0.000 msec
Cyl_6_TrimPoint_10 0.000 msec
PGR017_E_TRIM_Cyl_7_CurrentDurationTrim_Reserved_NonNafta
Cyl_7_TrimPoint_1 0.000 msec
Cyl_7_TrimPoint_2 0.000 msec
Cyl_7_TrimPoint_3 0.000 msec
Cyl_7_TrimPoint_4 0.000 msec
Cyl_7_TrimPoint_5 0.000 msec
Cyl_7_TrimPoint_6 0.000 msec
Cyl_7_TrimPoint_7 0.000 msec
Cyl_7_TrimPoint_8 0.000 msec
Cyl_7_TrimPoint_9 0.000 msec
Cyl_7_TrimPoint_10 0.000 msec
PGR018_E_TRIM_Cyl_8_CurrentDurationTrim_Reserved_NonNafta
Cyl_8_TrimPoint_1 0.000 msec
Cyl_8_TrimPoint_2 0.000 msec
Cyl_8_TrimPoint_3 0.000 msec
Cyl_8_TrimPoint_4 0.000 msec
Cyl_8_TrimPoint_5 0.000 msec
Cyl_8_TrimPoint_6 0.000 msec
Cyl_8_TrimPoint_7 0.000 msec
Cyl_8_TrimPoint_8 0.000 msec
Cyl_8_TrimPoint_9 0.000 msec
Cyl_8_TrimPoint_10 0.000 msec
PGR019_E_TRIM_NozzleBeginTrim
Cyl_1_NozzleBeginTrim -0.010 msec
Cyl_2_NozzleBeginTrim -0.010 msec
Cyl_3_NozzleBeginTrim -0.010 msec
Cyl_4_NozzleBeginTrim -0.038 msec
Cyl_5_NozzleBeginTrim -0.031 msec
Cyl_6_NozzleBeginTrim -0.024 msec
Cyl_7_NozzleBeginTrim 0.000 msec
Cyl_8_NozzleBeginTrim 0.000 msec
PGR020_E_TRIM_NozzleEndTrim
Cyl_1_NozzleEndTrim 0.003 msec
Cyl_2_NozzleEndTrim -0.003 msec
Cyl_3_NozzleEndTrim -0.031 msec
Cyl_4_NozzleEndTrim 0.073 msec
Cyl_5_NozzleEndTrim -0.017 msec
Cyl_6_NozzleEndTrim 0.045 msec
Cyl_7_NozzleEndTrim 0.000 msec
Cyl_8_NozzleEndTrim 0.000 msec
PGR021_E_TRIM_PumpPull_InTrim
Cyl_1_PumpPull_InTrim 0.010 msec
Cyl_2_PumpPull_InTrim -0.010 msec
Cyl_3_PumpPull_InTrim -0.017 msec
Cyl_4_PumpPull_InTrim -0.017 msec
Cyl_5_PumpPull_InTrim -0.003 msec
Cyl_6_PumpPull_InTrim -0.010 msec
Cyl_7_PumpPull_InTrim 0.000 msec
Cyl_8_PumpPull_InTrim 0.000 msec
PGR022_E_TRIM_PumpEndTrim
Cyl_1_PumpEndTrim 0.017 msec
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 27 of 42
PGR023_E_TRIM_PumpLeakageTrim
Cyl_1_PumpLeakageTrim 0.000 msec
Cyl_2_PumpLeakageTrim 0.000 msec
Cyl_3_PumpLeakageTrim 0.000 msec
Cyl_4_PumpLeakageTrim 0.000 msec
Cyl_5_PumpLeakageTrim 0.000 msec
Cyl_6_PumpLeakageTrim 0.000 msec
Cyl_7_PumpLeakageTrim 0.000 msec
Cyl_8_PumpLeakageTrim 0.000 msec
PGR024_SensorConfig_2
Intake Manifold Pressure Enabled
Position of Intake Air Throttle Not Active
Exhaust Pressure before DPF Inlet Not Active
Outlet Temperature DOC Not Active
Inlet Temperature DOC Not Active
Outlet Temperature DPF Not Active
Turbo Compressor Outlet Temperature Not Active
Turbo Compressor Inlet Temperature Not Active
Pressure after DPF Outlet Not Active
Pressure after EGR Cooler Not Active
Turbo Compressor Outlet Pressure Not Active
Doser Pressure Outlet Not Active
VNT Position Not Active
Differential Pressure EGR (Venturi) Not Active
Differential Pressure after Compressor Outlet Not Active
Differential Pressure before Compressor Inlet Not Activated
CAC Outlet Temperature Not Active
EGR Valve Position Not Active
Coolant Temperature Out Active
Oil Level (Engine) Not Active
Turbocharger Speed Not Active
Reserved Temperature Signal 1 Not Active
HDMS Thermal Switch Config Disabled
Reserved Temperature Signal 3 Not Active
Reserved Temperature Signal 4 Not Active
PGR025_EBMConfig
Turbobrake Enable Not Active
Hydraulic Konstant Drossel Enable Not Installed
Jake Brake 1 Enable Active
Jake Brake 2 Enable Active
CAN Actuator 1 Wastegate Not Active
CAN Actuator 3 EGR Not Active
CAN Actuator 5 VGT Not Active
CAN Actuator 2 Not Active
CAN Actuator 4 Not Active
PGR026_Analog_Value_List_1
analog value list1, number of analog values 2
analog value list1, analog value number 1 43
analog value list1, analog value number 2 44
analog value list1, analog value number 3 0
analog value list1, analog value number 4 0
analog value list1, analog value number 5 0
analog value list1, analog value number 6 0
analog value list1, analog value number 7 0
analog value list1, analog value number 8 0
analog value list1, analog value number 9 0
analog value list1, analog value number 10 0
analog value list1, analog value number 11 0
analog value list1, analog value number 12 0
analog value list1, analog value number 13 0
analog value list1, analog value number 14 0
analog value list1, analog value number 15 0
analog value list1, analog value number 16 0
analog value list1, analog value number 17 0
analog value list1, analog value number 18 0
analog value list1, analog value number 19 0
PGR027_Analog_Value_List_2
analog value list2, number of analog values 14
analog value list2, analog value number 1 4
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 28 of 42
PGR028_Analog_Value_List_3
analog value list3, number of analog values 16
analog value list3, analog value number 1 20
analog value list3, analog value number 2 24
analog value list3, analog value number 3 38
analog value list3, analog value number 4 18
analog value list3, analog value number 5 54
analog value list3, analog value number 6 56
analog value list3, analog value number 7 57
analog value list3, analog value number 8 59
analog value list3, analog value number 9 61
analog value list3, analog value number 10 25
analog value list3, analog value number 11 65
analog value list3, analog value number 12 66
analog value list3, analog value number 13 39
analog value list3, analog value number 14 62
analog value list3, analog value number 15 36
analog value list3, analog value number 16 37
analog value list3, analog value number 17 0
analog value list3, analog value number 18 0
analog value list3, analog value number 19 0
PGR029_Analog_Value_List_4
analog value list4, number of analog values 12
analog value list4, analog value number 1 29
analog value list4, analog value number 2 30
analog value list4, analog value number 3 31
analog value list4, analog value number 4 32
analog value list4, analog value number 5 33
analog value list4, analog value number 6 34
analog value list4, analog value number 7 35
analog value list4, analog value number 8 68
analog value list4, analog value number 9 69
analog value list4, analog value number 10 70
analog value list4, analog value number 11 22
analog value list4, analog value number 12 23
analog value list4, analog value number 13 0
analog value list4, analog value number 14 0
analog value list4, analog value number 15 0
analog value list4, analog value number 16 0
analog value list4, analog value number 17 0
analog value list4, analog value number 18 0
analog value list4, analog value number 19 0
PGR030_Analog_Value_List_5
analog value list5, number of analog values 13
analog value list5, analog value number 1 16
analog value list5, analog value number 2 14
analog value list5, analog value number 3 13
analog value list5, analog value number 4 67
analog value list5, analog value number 5 17
analog value list5, analog value number 6 55
analog value list5, analog value number 7 58
analog value list5, analog value number 8 60
analog value list5, analog value number 9 42
analog value list5, analog value number 10 63
analog value list5, analog value number 11 40
analog value list5, analog value number 12 41
analog value list5, analog value number 13 53
analog value list5, analog value number 14 0
analog value list5, analog value number 15 0
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 29 of 42
PGR031_Analog_Value_List_6
analog value list6, number of analog values 5
analog value list6, analog value number 1 21
analog value list6, analog value number 2 19
analog value list6, analog value number 3 15
analog value list6, analog value number 4 64
analog value list6, analog value number 5 26
analog value list6, analog value number 6 0
analog value list6, analog value number 7 0
analog value list6, analog value number 8 0
analog value list6, analog value number 9 0
analog value list6, analog value number 10 0
analog value list6, analog value number 11 0
analog value list6, analog value number 12 0
analog value list6, analog value number 13 0
analog value list6, analog value number 14 0
analog value list6, analog value number 15 0
analog value list6, analog value number 16 0
analog value list6, analog value number 17 0
analog value list6, analog value number 18 0
analog value list6, analog value number 19 0
PGR032_Analog_Value_List_7
analog value list7, number of analog values 8
analog value list7, analog value number 1 45
analog value list7, analog value number 2 46
analog value list7, analog value number 3 47
analog value list7, analog value number 4 48
analog value list7, analog value number 5 49
analog value list7, analog value number 6 50
analog value list7, analog value number 7 51
analog value list7, analog value number 8 52
analog value list7, analog value number 9 0
analog value list7, analog value number 10 0
analog value list7, analog value number 11 0
analog value list7, analog value number 12 0
analog value list7, analog value number 13 0
analog value list7, analog value number 14 0
analog value list7, analog value number 15 0
analog value list7, analog value number 16 0
analog value list7, analog value number 17 0
analog value list7, analog value number 18 0
analog value list7, analog value number 19 0
PGR033_Binary_Value_List_1
binary value list1, number of binaryvalues 4
binary value list1, binary value number 1 1
binary value list1, binary value number 2 2
binary value list1, binary value number 3 6
binary value list1, binary value number 4 13
binary value list1, binary value number 5 0
binary value list1, binary value number 6 0
binary value list1, binary value number 7 0
binary value list1, binary value number 8 0
binary value list1, binary value number 9 0
binary value list1, binary value number 10 0
binary value list1, binary value number 11 0
binary value list1, binary value number 12 0
binary value list1, binary value number 13 0
binary value list1, binary value number 14 0
PGR034_Binary_Value_List_2
binary value list2, number of binaryvalues 3
binary value list2, binary value number 1 3
binary value list2, binary value number 2 4
binary value list2, binary value number 3 7
binary value list2, binary value number 4 0
binary value list2, binary value number 5 0
binary value list2, binary value number 6 0
binary value list2, binary value number 7 0
binary value list2, binary value number 8 0
binary value list2, binary value number 9 0
binary value list2, binary value number 10 0
binary value list2, binary value number 11 0
binary value list2, binary value number 12 0
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 30 of 42
PGR035_Binary_Value_List_3
binary value list3, number of binaryvalues 6
binary value list3, binary value number 1 5
binary value list3, binary value number 2 8
binary value list3, binary value number 3 10
binary value list3, binary value number 4 11
binary value list3, binary value number 5 12
binary value list3, binary value number 6 9
binary value list3, binary value number 7 0
binary value list3, binary value number 8 0
binary value list3, binary value number 9 0
binary value list3, binary value number 10 0
binary value list3, binary value number 11 0
binary value list3, binary value number 12 0
binary value list3, binary value number 13 0
binary value list3, binary value number 14 0
PGR040_Oil_Level
isp_l_oil_oilsump_dat_val_b Disabled
Oil Norm Eng On EOL x0 0.00 %
Oil Norm Eng On EOL x1 0.00 %
Oil Norm Eng On EOL x2 0.00 %
Oil Norm Eng On EOL x3 0.00 %
Oil Norm Eng On EOL x4 0.00 %
Oil Norm Eng On EOL y0 0.00000 gal
Oil Norm Eng On EOL y1 0.00000 gal
Oil Norm Eng On EOL y2 0.00000 gal
Oil Norm Eng On EOL y3 0.00000 gal
Oil Norm Eng On EOL y4 0.00000 gal
Oil Norm Eng Off EOL x0 0.00 %
Oil Norm Eng Off EOL x1 0.00 %
Oil Norm Eng Off EOL x2 0.00 %
Oil Norm Eng Off EOL x3 0.00 %
Oil Norm Eng Off EOL x4 0.00 %
Oil Norm Eng Off EOL y0 0.00000 gal
Oil Norm Eng Off EOL y1 0.00000 gal
Oil Norm Eng Off EOL y2 0.00000 gal
Oil Norm Eng Off EOL y3 0.00000 gal
Oil Norm Eng Off EOL y4 0.00000 gal
MinMaxValue 0.00000 gal
Prewarning Threshold 0.00000 gal
Warning Threshold 0.00000 gal
Warnbuzzer Threshold 0.00000 gal
UPP Warn Threshold 0.00000 gal
OBD Warn Threshold 0.00000 gal
Refill Threshold 0.00000 gal
Measurement Mode no measurement
Oil Sump Type oil sump type 0
Acoustic Signaling
par_air_horn not present
par_horn_foot_switch not present
par_horn_selector_switch momentary
par_horn_selector_switch_config electric horn with horn request/nothing with foot switch
Air Intake
par_air_filter_restriction_input not present
Alternator Accessories
par_alternator_charging_input_config disable
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 31 of 42
Bulb Out
par_bulb_out_fault_indicator feature not present
Cruise Control
par_cruise_control_disengage CC disengage input not present
DC Power Outlet/Receptacle
par_power_receptacle_6_control BAT Power
Diagnostics
par_DM1_reporting_config disable
Door Module
par_door_module_exists not present
par_door_open_warning_lamp_exists not present
Engine Control
par_powertrain_wakeup_timer 0s
par_engine_cool_down_timer 0s
par_engine_coolant_temp_threshold -40 °C
Footwell Lighting
par_footwell_lighting not present
par_footwell_lighting_ramp_up_time step behaviour
par_footwell_lighting_ramp_down_time step behaviour
HVAC
par_HVAC_pressure_transducer present
par_CM1_mirror_mode_config disable
par_HVAC_controller_power_config CONSIDER CURRENT LIMITATION EVENTS
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 32 of 42
par_dome_lamp_switch_type momentary
par_mid_dome_lamp present
par_mid_dome_lamp_control_type Theater Lighting
par_dome_lamp_max_cut_off_level 100%
par_dome_lamp_theater_ramp_time step behaviour
par_int_lighting_cut_off_speed 0.0 mph
par_int_lighting_dimmable_ramp_time_quick step behaviour
Marker Lamps
par_marker_lamp_interrupt_present on
Marker Tractor/Marker Trailer/Tail Tractor/Tail
par_marker_lamp_interrupt_config
Trailer/Clearance Tractor affected
par_marker_lamp_interrupt_cycles 0 cycles
Mirror Heat
par_mirror_heating_exists yes
Optimized Idle
par_optimized_idle not present
par_optimized_idle_vps not present
par_optimized_idle_vps_control CAN signal only
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 33 of 42
Powernet
par_PNM_variant LVD
Powernet LVD
par_LVD_level1 12.50 V
par_LVD_level2 12.50 V
par_LVD_level3 12.05 V
par_LVD_level4 12.30 V
Pre-Trip Inspection
par_bulb_check_config disable
par_bulb_check_lamp_group_active_time 1000 ms
par_bulb_check_active_cycles 0 cycles
Safety
Hazard Lights activated deactivated
Dome Lamps activated deactivated
Ignition (IGN_1) deactivated deactivated
Accessory (ACC_1) deactivated deactivated
par_SRS_airbag_module not present
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 34 of 42
par_byte_number_CAN_event_1_1_1 0
par_operation_CAN_event_1_1_1 None
par_2_4_6_8_16_bitinfo_event_1_1_1 2 Bit
par_position_2_4_6_bitinfo_event_1_1_1 Pos0
par_CAN_event_1_1_1 no
par_activate_in_case_of_signal_failure_CAN_event_1_1_1 no
par_link_input_CAN_event_1_1 or
Constant Reserved_0 00
Constant Reserved_1 00
Constant Reserved_2 00
Constant Reserved_3 00
Constant Reserved_4 00
Constant Reserved_5 00
Constant Reserved_6 00
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 35 of 42
par_CAN_event_2_1_2 no
par_activate_in_case_of_signal_failure_CAN_event_2_1_2 no
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 36 of 42
Starter control
par_clutch_switches_controlled_by_SAM yes
par_crank_interlock_exists not present
par_starter_relay_logic_config BOC
par_starter_relay_output_control SAM CAB
par_OFF_Switch_exist not present
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 37 of 42
par_abutment_crank_attempts 1 attempts
par_abutment_detection_voltage_threshold 0.00 V
par_abutment_voltage_drop_threshold 0.00 V
par_abutment_detection_delay 0 ms
par_abutment_reactivation_delay 0 ms
par_quick_crank_delay_time 3000 ms
Utility Lamps
par_utility_lamp_cutoff_speed 9.9 mph
par_utility_lamp present
par_utility_lamp_override enable
par_utility_lamp_activation_with_backup disable
Windshield Wiper
par_wiper_adjust_with_park_brake DISABLED
par_wiper_adjust_with_vehicle_speed DISABLED
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 38 of 42
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 39 of 42
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 40 of 42
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 41 of 42
ID not available
ID274 not available
ID275 not available
ID276 not available
ID277 not available
ID278 not available
ID279 not available
ID280 not available
ID281 not available
ID282 not available
ID283 not available
ID284 not available
ID285 not available
ID286 not available
ID287 not available
ID288 not available
ID289 not available
ID290 not available
ID291 not available
ID292 not available
ID293 not available
ID294 not available
ID295 not available
ID296 not available
ID297 not available
ID298 not available
ID299 not available
ID300 not available
ID301 not available
ID302 not available
ID303 not available
ID304 not available
Backup Lamps
par_backup_lamp_config present
par_backup_switch_available yes
Diagnostics
par_DM1_reporting_config enable
Differential Locks
par_diff_lock_disengage_speed 0.0000 mph
par_diff_lock_max_engage_speed 0.0000 mph
par_diff_lock_engage_delay 0s
par_turn_off_on_locks_via_abs_bs_interaction interaction not allowed
par_difflock_interaxle_indicator_config low-end ICU indicators actuated by RA
par_rear_axle_1_sensor not present
par_rear_axle_2_sensor not present
par_transfer_gearbox not present
par_differential_lock_feedback_switch_RA1 not present
par_differential_lock_feedback_switch_RA2 not present
par_differential_lock_feedback_switch_FA1 not present
par_differential_lock_feedback_switch_FA2 not present
par_diff_lock_solenoid_RA not present
par_diff_lock_Solenoid_FA not present
Engine Brake
par_stop_lamps_active_with_engine_brake_or_retarder stop lamps not active with engine brake or retarder
Fuel Level
par_fuel_level_filtering_enabled on
par_sender_present fuel level sensor present
about:blank 10-17-2023
Parameters (VIN:1FUJGLCK68LZ66... Page 42 of 42
Neutral Switch
par_neutral_switch_available yes
Powernet
par_PNM_variant LVD
Safety
par_SRS_controlled_outputs nothing activated
par_SRS_airbag_module not present
Trailer Configuration
par_boc_primary_trailer_power BAT
par_boc_primary_trailer_power_switch not present
par_trailer_primary_receptacle_config Back of cab and end of frame
par_boc_trailer_detection disable
par_boc_ABS_detection_input not present
par_eof_trailer_power_switch not present
about:blank 10-17-2023