STANDARD No.

satmae? ENGINEERS PERFORATED TRAY SUPPORTS

INDIA LIMITED AND 7-52-0107 Rev. 2
Ig,a19,TWE IA Gov/ at India Undenalang) CABLES CLAMPING DETAILS
Page 1 of 1

CABLE CLAMPING ON PERFORATED TRAYS

SINGLE CLAMPING FOR SINGLE CLAMPING FOR DUAL CLAMPING FOR CABLE CLAMPS DETAIL
TWO CABLES MULTIPLE CABLES MULTIPLE CABLES
DETAIL 'A' DETAIL 'B' DETAIL 'El" DETAIL 'A'
3 2mm THK
c=1.4
L. Js • • • it. I ••• oLj x rol

w -1-- lo DIA HOLE FOR

M8x35 LONG BOLT
WITH NUT
-v `9'
IIEJF!11111

= ==
== IT —— DETAIL 11'

II
0 — 01 ——
0 o — — 0

o o ' ca o 0 IllY ■o
II o o o o 0 o o O
o o o
7 30 o
c = ==c ===== 0 10 DIA HOLE FOR
i. = =
.—9 = ,=,
M8x45 LONG BOLT

____—\C.-- SEE 41 1'4

ELIPTICAL HOLES SUITABLE FOR
M8 BOLTS P. 'WHERE' DENOTES THE INSIDE
WIDTH OF TRAY
WHERE X = W -10 FOR
SINGLE CLAMPING

w - 10 FOR
-7
DUAL CLAMPING

PERFORATED TRAY - SUPPORTING DETAILS

TRAY ROUTING TRAY ROUTING TRAY ROUTING TRAY ROUTING
EDGEWISE EDGEWISE WIDTHWISE CONCRETE BEAM/COLUMN
HOR. / VER. RUNS IN HOR. / VER. RUNS IN HORIZONTAL RUNS IN HOR. / VER. PLANE

ANCHOR FASTENER OR
INSERT PLATE
(TYP.)

NOTES :- CAPACITY OF PERFORATED TRAYS

ALL DIMENSIONS ARE IN mm. TRAY FLANGE NO. OF CABLES
PERFORATED TRAYS SHALL BE SUPPORTED AT EVERY 1000 mm (TYP.) INTERVAL FOR WIDTH HEIGHT
HORIZONTAL AS WELL AS VERTICAL RUNS USING MINIMUM ANGLE SIZE AS 1 PAIR/ 6 PAIR/ 12 PAIR/
08i) (H)
40x40x5 OR CONTINOUS CHANNEL SUPPORT MC50 1 TRIAD 6 TRIAD 8TRIAD
CLAMPING OF CABLES ON PERFORATED TRAYS SHALL BE AT EVERY 500 mm ON 60 20 2
VERTICAL RUNS AND EVERY 1000 mm ON HORIZONTAL RUNS. 100 30 4 2
PERFORATED TRAYS SHALL BE SUPPLIED WITH CLAMPS, BOLTS / NUTS AND WASHERS OF
150 30 6 4 3
GALVANISED MILD STEEL.
GALVANISING SHALL BE AS PER IS 4759 (6601/ 460 g / m2) 200 30 10 6 4
THE PERFORATED TRAY THICKNESS SHALL BE 2 ram. 300 30 n c\15 8 6
2 14-11-11 Revised & Reissued '`irManoj 6ePG P/J fi DM
1 01-09-06 Reaffirmed and Reissued MN TGM PM VC
Rev. Prepared Checked Stds. Committee Stds. Bureau
Date Purpose Convenor Chairman
No. by by Approved by
Format No. 8-00-0001-F4 Rev.0 Copyright EIL - All rights reserved