Download as pdf or txt
Download as pdf or txt
You are on page 1of 21

NATIONAL

SENIOR CERTIFICATE
NASIONALE
SENIOR SERTIFIKAAT

GRADE 12/GRAAD 12

TECHNICAL MATHEMATICS P1/TEGNIESE WISKUNDE V1

NOVEMBER 2021

MARKING GUIDELINES/NASIENRIGLYNE

MARKS/PUNTE: 150

MARKING CODES/NASIENKODES
A Accuracy/Akkuraatheid
CA Consistent accuracy/Volgehoue akkuraatheid
M Method/Metode
R Rounding/Afronding
NPR No penalty for rounding/Geen penalisering vir afronding nie
NPU No penalty for units omitted Geen penalisering vir eenhede weggelaat nie
S Simplification/Vereenvoudiging
SF Substitution in correct formula/Vervanging in korrekte formule

These marking guidelines consist of 21 pages.


Hierdie nasienriglyne bestaan uit 21 bladsye.

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 2 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

NOTE:
 If a candidate answers a question TWICE, only mark the FIRST attempt.
 The method of consistent accuracy marking must be applied to all aspects of the
marking guideline where applicable as indicated with the marking code CA.
 If a candidate strikes off a response to a question and does not attempt the question again,
then the struck off question should be marked.
 # Shows questions where Tolerance Range will be applied:
3.3.2 ; 5.2 ; 5.3.2 ; 9.2
LET WEL:
 Indien 'n kandidaat 'n vraag TWEE keer beantwoord, sien slegs die EERSTE poging na.
 Die metode van volgehoue akkuraatheid-nasien moet waar moontlik op alle aspekte
van die nasienriglyne toegepas word soos aangedui deur die nasienkode CA.
 Indien ʼn kandidaat ʼn antwoord deurhaal en nie poog om die vraag weer te beantwoord dan
moet die deurgehaalde antwoord gemerk word.
 # Toon vrae waar Toleransie Wydte (Verdraagsaamheids omvang) toegepas word:
3.3.2 ; 5.2 ; 5.3.2 ; 9.2
QUESTION/VRAAG 1
1.1.1 2 x ( x  3)  0
x 0 or/of x 3  x 0 A
 x3 A
(2)
1.1.2 x ( x  9 )  12
x 2  9 x  12  0
 standard form/standaardvorm A
 b  b  4ac
2
x
2a
 9  92  4(1)(12)  SF CA

2(1)
 9  129

2
  each x -value/elke waarde CA
 x  1,18 or/of x  10,18
R (4)
1.1.3 x(6  x)  0
Critical values/kritiese waardes: 0 and 6  both critical values/ A
albei kritiese waardes
 0  x  6 OR/OF x  0 ; 6 OR/OF  notation/notasie A
x  0 and/en x  6
 number line representation/
getallelyn voorstelling CA
0 6
Note: Award full marks if
ONLY the correct number line
representation is shown.

Nota: Ken vol punte toe


SLEGS as korrekte getallelyn
getoon word

(3)
Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief
Technical Mathematics/P1/Tegniese Wiskunde/V1 3 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

1.2 x  1  2 y and/en 3x 2  3  x  y
31  2 y   3  (1  2 y)  y
2
 substitution/vervanging A
3  12 y  12 y  4  y
2
S CA
12 y  11y  1  0
2 correct standard form/
korrekte standaard vorm CA
(12 y  1)( y  1)  0 OR/OF

1  factors/formula /
y    0,08 or/of y  1 faktore/formule. CA
12
1  both y-values/-waardes CA
x  1  2( ) or/of x  1  2 (1)
12
7
 x   1,17 or/of x   1  both x-values/-waardes CA
6
OR/OF OR/OF
1 x
y and/ en 3x  3  x  y
2

1 x  substitution/ vervanging
3x 2  3  x  A
2

6x2  6  2x  1  x S CA
 correct standard form/
6x2  x  7  0 korrekte standaardvorm CA
(6 x  7)( x  1)  0 OR/OF  factors/form./faktore/form. CA
7  both x-values/-waarde CA
 x   1,17 or/of x  1
6
7
1
y 6 or/of y  1  (1)
2 2
1  both y-values/-waardes CA
 y     0,08 or/of y  1
12
OR/OF OR/OF

x  1  2 y 1 and / en 3x 2  3  x  y  2 
Sub/verv  2  into/in 1


x  1 2 3x 2  3  x   substitution/ vervanging A

x  1 6 x2  6  2 x S CA
6 x2  x  7  0  correct standard form/
korrekte standaardvorm CA
 6 x  7  x 1   0  factors/form./faktore/form. CA
7 OR/OF
x   1,17 or/of x  1  both x-values/-waarde CA
6
1
 y     0,08 or/of y  1  both y-values/-waardes CA
12 NPR
(6)
Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief
Technical Mathematics/P1/Tegniese Wiskunde/V1 4 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

L
1.3.1 T  2
g
T L

2 g
2 2
 T  L  M squaring both sides/
    
 2  g kwadreer beide kante A
2
 T   L subject/ onderwerp A
L  g   
 2 

OR/OF OR/OF

L
T  2
g
2
 
T    2  L 
2

 g  M squaring both sides/


L kwadreer beide kante A
T 2  4 2
g
gT 2  L subject/ onderwerp A
L
4 2
(2)
2
 T 
1.3.2 L  g   
 2 
2
 1,74 
L  9 , 8     SF CA
 2 
L  0 , 75 m  value of/waarde van L CA

OR/OF OR/OF

gT2
L
4 2

L
9,81,74
2  SF CA
4 2
L  0 , 75 m  value of/waarde van L CA

OR/OF
OR/OF

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 5 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

L
T  2
g
L
1,74  2 
9,8  SF A
2
 1,74 
L  9 , 8   
 2 
L  0, 75 m
 value of/waarde van L CA
NPR NPU
(2)
1.4.1 1101100 2 11100 2  1010000 2  10100002 A
Note: No penalty if base 2 is
omitted.

Nota: geen penaliseering


indien basis 2 uitgelaat is
(1)
1.4.2 2 6
2 5
2 4
2 3
2 2
2 1
2 0

1 0 1 0 0 0 0 M CA

 64  16  80  decimal value/desimale waarde


CA

OR/OF
OR/OF
6 5 4 3 2 1 0
2 2 2 2 2 2 2
1 1 0 1 1 0 0 =108

1 1 1 0 0 =28 M A

 108  28  80  decimal value/desimale waarde


CA

AO: full marks/ vol punte

(2)
[22]

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 6 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

QUESTION/VRAAG 2

2.1.1 Non-real/ nie-reël  non-real/ nie-reël


(1)
2.1.2 Real, rational, equal  Real, rational, equal/
Reëel, rasionaal, gelyk Reëel, rasionaal, gelyk A

(1)
2.2  x  2qx  4  0
2
OR/OF x  2qx  4  0
2

  <0 A
b  4ac  0
2

2q2  4 1 4  0 OR/OF  2q2  4 14  0  SF A


4q  16  0
2

q2  4  0
q  2q  2  0
 2  q  2 OR/OF q  (2 ; 2) OR/OF q   2 and q  2 end points and correct
notation/ eindpunte en
korrekte notasie CA
(3)
[5]

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 7 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

QUESTION/VRAAG 3
3.1.1
81a 
3
8  4

= 3 a 
3

4 8 4
 Prime base or exponential
1 6 a6 property/ priembasis of
3 6
= 3 a OR/OF a OR / OF eksponensiële eienskap A
27 27 3 3
CA
 a 6
A
AO: 2 marks/punte
(3)
3.1.2 log 2 16  log 3 4 0
4
 log 2 2 A
 log 2 24  log 3 1
 4 log 2 2  log 3 1  log 3 1 A
 41  0  log 2 2  1 CA
4  4 CA

OR/OF
OR/OF
log 2 16  log 3 40  log 2 2
4
A
 log 2 2  0 log 3 4
4
 4 log 2 2  0 log 3 4 A
 4 log 2 2  0 log 3 4  log 2 2  1 CA
 4(1)  0 4 CA
4
OR/OF OR/OF

log 2 16  log 3 4 0
log 16 log 4 0 log 2 4
   A
log 2 log 3 log 2
log 2 4 log 1 log 1
   A
log 2 log 3 log 3
4 log 2 0 4 log 2
   CA
log 2 log 3 log 2
40
 4 CA
4
AO: 3 marks/punte
(4)

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 8 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

3.1.3 50 x10  18x 4


 900 x 6  Product of the surds/ produk van
wortelvorm A
 30 x 3
 30 CA
 x3 CA

OR/OF OR/OF

50 x10  18x 4
 Product of perfect squares and
 25  2 x10  9  2 x 4
prime number/
 5 2 x5  3 2 x 2 produk van volkome vierkante en
 30x3 priem getalle A
 30 CA
 x 3
CA
(3)
3.2 log 3 ( x  2)  2  log 3 x
log 3 ( x  2)  log 3 x  2
x2
log 3 2  log property/log-eienskap A
x
x2 x2 exponential/log form/
 32 OR/OF log 3  2log 3 3
x x eksponensiële /log vorm CA
x  2  9x S CA
1
x OR/OF x  0,25  x – value/waarde CA
4

OR/OF OR/OF

log 3 ( x  2)  2  log 3 x
log 3 ( x  2)  2log 3 3  log 3 x  log property/log-eienskap A

log 3 ( x  2)  log 3 9  log 3 x  log property/log-eienskap A


log 3 ( x  2)  log 3 9 x
S CA
x  2  9x
1  x – value/waarde CA
x OR/OF x  0,25
4 (4)
3.3.1 z  r  x2  y 2
2 5 = p + 4
2 2

 SF A
20 = p 2 + 16
p 2 = 4 OR / OF ( p + 2) ( p  2) = 0 OR / OF p = ± 4 S CA
p = ±2
S CA
 p = 2 , θ  (90 o ;180 o )
–2 CA

(4)

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 9 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

3.3.2 y x
tan   OR/OF cos  
x r
# 4 2
tan   OR/OF cos  
2 2 5
ref .angle / verw. hoek  63,43o  ref. angle/verw. hoek CA

 180o  63,43o 116,57 o OR/OF 2,03 rad  value of/ waarde van  CA

 z  2 5 cis 116,57 o OR/OF  z in polar form/polêre vorm CA

 z  2 5 cis 2,03 rad OR/OF

OR/OF
y
sin  
r
4
sin  
2 5

ref .angle / verw. hoek  63,43o  ref. angle / verw. hoek A

 180o  63,43o 116,57 o OR/OF 2,03 rad  value of/ waarde van  CA

 z  2 5 cis 116,57 o OR/OF  z in polar form/polêre vorm CA


 z  2 5 cis 2,03 rad (3)
3.4 2m  ni  6i   3i (4i  5)
2m  ni   12 i 2  15i  6i  Product/ produk A
2m  ni   12(1)  9i 2
 substituting i with – 1/
2m  ni  12  9i
2
vervang i met – 1 A

 2m  12
m6  value of/ waarde van m CA
  ni   9i
n9
 value of/ waarde van n CA

OR/OF OR/OF

2m  ni  6i   3i(4i  5)
2m  (n  6) i   12 i 2  15 i  Product/ produk A
2m  (n  6) i   12 (1)  15i 2
 substituting i with – 1/
2m  (n  6) i  12  15i 2
vervang i met – 1 A
 2m  12
m6  value of/ waarde van m CA
  (n  6) i   15i
 value of/ waarde van n CA
n9

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 10 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

OR/OF OR/OF
2m  ni  6i   3i(4i  5)
2m  (n  6) i   12 i 2  15 i  Product/ produk A
2m  ni  6i   12 (1)  15i 2
 substituting i with – 1/
2
2m  ni  6i  12  15i vervang i met – 1 A
 2m  12  ni  6i  15i
2m 12  0 and / en ni  9i  0
 2m  12
m6  value of/ waarde van m CA

 ni  9i
n 9  value of/ waarde van n CA
(4)
[25]

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 11 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

QUESTION/VRAAG 4

4.1.1(a) y  6 OR/OF (0 ; 6 ) 6 A
(1)
4.1.1(b) y5  y5 A
(1)
4.1.1(c) k ( x )   2x 2  4x  6
 y-int./ afsn.
y  int / afsn.: y  6 A

x  ints/afsn..:
 2x 2  4x  6  0
x 2  2x  3  0
factors/form./faktore/form. A
( x  1) ( x  3)  0 OR/OF x    2   2  41 3
2

21
x   1 or / of x  3  both values of/ beide
waardes van x CA
(3)
4.1.1(d) TP/DP,
 b  4
x 
2a 2 2 SF A

1  x-value/waarde CA
y   2 (1)  4 (1)  6  8
2
 y-value/ waarde CA
 1; 8
OR/OF
OR/OF
1  3 M
TP/DP, x  1 CA
2  x-value/waarde CA
y   2 (1) 2  4 (1)  6  8  y-value/ waarde CA
 1; 8
OR/OF OR/OF
k ( x )   2x  4x  6
2

k / (x )   4x  4  0
M A
x 1
 x-value/waarde CA
y   2 (1) 2  4 (1)  6  8
 y-value/ waarde CA
 1; 8
OR/OF OR/OF
  b 4ac  b  2
 ; 
 2 a 4 a 
  4 4 26  42  SF A
   x-value/waarde CA
 2 2 ;    
 4 2   y-value/ waarde CA
 1; 8

(3)

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 12 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

4.1.2

h:
 shape/vorm A
 y- int./afsn CA
 asymptote/ asimptote CA

k:
 shape/vorm A
 x & y int../afsn CA
Turning point/ draaipt CA
(6)

4.1.3 a
p( x)   q and/en  1; 8
x
q5  value of/ waarde van q A
a
8 5  SF A
1
a   3  value of/ waarde van a CA
(3)
4.2.1 C 5 ; 0   x-value at/waarde by C A
 y-value at/ waarde by C A
(2)
4.2.2 D 0 ; 10  and/en B 0 ;  5  coordinates of/ koördinate
van B & D CA
BD   5  (10)  5 units / eenhede  length of/ lengte van BD
CA
AO: Full marks/Volpunte

(2)
4.2.3 f ( x)   25  x 2 OR/OF f ( x)   52  x 2  equation/vergelyking CA
(1)
4.2.4 3  x  5 OR/OF x( 3; 5 ) OR/OF x  3 and x  5  critical values/ kritiese
waardes CA
 correct notation/
korrekte notasie A
(2)
[24]

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 13 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

QUESTION/VRAAG 5
4
5.1.1 17 , 39 %  17 , 39 % A
23
NPR
(1)
5.1.2 A  P1  i n
 4 
A  R63 150 1   7  OR/ OF R63 150 1  17, 39 %  7   SF A
 23 
 R140028, 26 CA
 R140028, 26  R140022,50
OR/OF
OR/OF
SI / ER = P× i × n
4  SF A
 R63 150  7 OR/OF
23
 R63150 17,39%  7
 R76 878, 26  R76 872,50
 R140028, 26 CA
A  R63 150  R76 878, 26 OR/OF
NPR
R 63150  R76 872,50
(2)
»R140 028, 26  R140 022,50

A  P 1  i 
n
5.2

# R274 000  R726 900 1  15,8%  n  SF A


2 740
 1  15,8%  n S CA
7 269
 2 740 
log   log form/vorm
7 269 
CA
n 
log( 0,842)
n  5,67
 n  5, 67 years/jare  value of/ waarde van n CA
(4)
5.3.1 A  P1  i  n
 R25 000 1  2,8%  4  SF A
 R 27 919,81 CA
 R 27 919,81
(2)

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 14 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

5.3.2 Value of investment after 27 months/


Waarde van belegging na 27 maande

A  P1  i 
n
#
27
 5,98%   5,98% 
27
 R15 000 1    1   A
 12   12 
 R17154,59482 value of/ waarde van A CA
Value of investment after 21 months/
Waarde van belegging na 21 maande

P  R17154,59482  R 6823,54  R 23 978, 13482 M adding/ byvoeging R6 823,54


Value of investment after 7 quarters/ A
Waarde van belegging na 7 kwartale
7
 7,78% 
7
 7,78% 
 R23 978, 13482 1    1   A
 4   4 
 R 27 439, 55
 R 27 439, 55  R 27 919,81  value of/ waarde van A CA
He will not have enough money/ hy sal nie genoeg conclusion/ gevolgtrekking CA
geld hȇ nie
OR/OF OR/OF
27
 5,98% 
 5,98% 
27
 7,78% 
7
 1   A
A  R15 000 1   1    12 
 12   4  7
 7,78% 
 1   A
 7,78% 
7
 4 
+ R6 823,54 1  
 4  M A
7
 7,78% 
 R 27 439, 55  1   A
 4 
 R 27 439, 55  R 27 919,81   R 27 439, 55 CA
conclusion/gvlgtr CA
He will not have enough money/ hy sal nie genoeg geld hȇ nie
OR/OF OR/OF
27
 5,98% 
 27   7, 78% 7  1   A
 5,98%   12 
A   R15 000 1    R6 823,54  1  
  12    4   M A
 R 27 439,55  M A
7
 7,78% 
 R 27 439, 55  R 27 919,81  1   A
 4 
He will not have enough money/ hy sal nie genoeg geld hȇ nie   R 27 439, 55 CA
conclusion/gvlgtr CA
(6)
Conclusion without calculation: 0 marks/ Gevolgtrekking sonder berekeninge gee: 0 punte
[15]
Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief
Technical Mathematics/P1/Tegniese Wiskunde/V1 15 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

QUESTION/VRAAG 6

6.1 f ( x )   3x
f ( x  h) f ( x)
f / ( x )  lim definition/definisie A
h0 h
 3 ( x  h )  (  3x)
 lim  SF CA
h0 h
 3 x  3h  3 x
 lim S CA
h0 h
 3h
 lim S CA
h0 h
 lim (  3)
h0

 f ( x)   3
/
–3 CA

AO: 1 mark/ punt

Penalty of one mark for


incorrect notation

Penaliseer een punt


indien notasie foutief is.

(5)
6.2.1 
D x p 3 x 2  7 x  10 
 2 p3 x  7 3
 2p x A
 7 A
(2)
6.2.2 x  3x 2
y
x7
y  x  6  3x  5 S A
dy
  6 x  7  15 x  6 7
dx   6x CA
 15 x  6 CA
(3)
6.2.3 f ( x )  x  5x
3 2 4

2 2
f ( x )  x 3  5x 4  x3 A
1
2  1
 f / (x )  x 3
 20 x 3 2 3
 x CA
3 3
 20x 3 A
(3)

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 16 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

6.3.1 m9  value of/ waarde van m A


(1)
6.3.2 y  x 2  3x  2
dy
 2x  3  derivative of / afgeleide van y
dx A
2x  3   9  equat.deriv/ verg. afgeleide
2 x  12 =–9 CA
 x  6  value of/ waarde van x CA
y  (  6 ) 2  3 ( 6 )  2
 y  16
 value of/ waarde van y
(  6 ; 16 )
CA

(4)
6.3.3 g ( x)  x  3x  2
2

g ( x)  ( 2) 2  3( 2)  2   4
g ( x)  (3) 2  3(3)  2  16  both values of/ beide waardes
y  y1 van y A
Ave. grad./Gem grad  2
x2  x1
16  ( 4)  M subst. into Ave. gradient

3  ( 2) Formula/verv in gem grad
20 vorm CA

5
4
 mave value/ waarde CA

OR/OF OR/OF

g ( x)  x 2  3x  2
g( x2 )  g( x1 )
Ave. grad./Gem grad 
x2  x1  M subst. into Ave. gradient

(3) 2
 
 3(3)  2  (2)  3( 2)  2
2
 Formula/verv. in gem grad
3  ( 2) vorm A
16  ( 4)  both values of/ beide waardes

3  ( 2) van y CA
20

5
4  mave value/ waarde CA
(3)
[21]

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 17 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

QUESTION/VRAAG 7

7.1 f ( x)  x 3  2 x 2  7 x  4
y   4 OR/OF 0 ;  4
 y-intercept/ afsnit A
(1)

7.2 f (4)  (4) 3  2(4) 2  7(4)  4  substitution/ vervanging A


0 0 A
 ( x  4) is a factor of/ is ʼn faktor van f (x)
(2)
7.3 x-intercepts/afsnitte; y  0
( x  4)( x 2  2 x  1)  0  quadratic factor/ kwdr. faktor A
( x  4 ) ( x 1) ( x  1)  0  factors/ faktore CA
 x  1 or x  4  x-intercepts/ afsnitte CA

OR/OF OR/OF
( x  1)( x  3x  4)  0
2
 quadratic factor/ kwdr faktor A
( x  1) ( x  4 ) ( x  1)  0  factors/ faktore CA
 x  1 or x  4  x-intercepts/ afsnitte CA
AO: Full marks/Volpunte
(3)
7.4 f ( x)  3 x  4 x  7  0
/ 2 derivative/afgeleide A
equating derivative to 0/
(3x  7) ( x  1)  0 OR/OF x    4   4  43 7
2

stel afgeleide gelyk aan 0 A


23
factors/formula/faktore CA
7 both values of /beide waardes
x  or/of x  1
3 van x CA
3 2
7  7 7 7 500
f       2   7   4     18, 52  both values of /beide waardes
3  3 3 3 27
van y CA
7 500 
  ;  and /en 1 ; 0
3 27 
OR/OF
2,33 ;  18,52 and /en 1 ; 0 (5)
7.5

 shape /vorm A
 y-intercept/ afsnit CA
 both x-intercepts/ beide x-afsnitte
CA
 both turning points/ beide
draaipunte CA

(4)
Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief
Technical Mathematics/P1/Tegniese Wiskunde/V1 18 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

7.6 7  crit. values/ krit. waarde CA


1  x  OR/OF 1  x  2,33  correct notation /
3
korrek notasie A
OR/OF
OR/OF
 7
x  1 ;  OR/OF x   1 ; 2,33  crit. values/ krit. waarde CA
 3  correct notation /
korrek notasie A
OR/OF OR/OF

7  crit. values/ krit. waarde


x   1 and/en x  OR/OF x   1 and/en x  2,33 CA
3  correct notation /
korrek notasie A
(2)
[17]

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 19 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

QUESTION/VRAAG 8

8.1 V lb h
4 000  x 2h  SF A
4 000
h  (1)
x2
8.2 Tot. Surface Area = length  breadth + 2  length  height
+2  breadth  height
Tot. Buite oppervlakte = lengte  breedte + 2  lengte   SF A
height +2  breedte  height
Tot. Surface Area/ Buite Oppervlakte  x 2  2 xh  2 xh S . CA

 4 000 
 x 2  4x  2 
 x 
16 000
 x2 
x
OR/OF OR/OF
Tot. Surface Area = Area of base + (perimeter of base 
height)
Tot. Buite Oppervlakte = oppervlakte van die basis +
(omtrek van basis  hoogte)
2
Tot. Surface Area/ Buite Oppervlakte  x  4 xh
 4 000 
 x 2  4x  2   SF A
 x 
16 000 S CA
 x2  .
x
(2)
8.3 16 000
Tot Surface Area/ Buite Oppe rvlakte  x 2 
x

 x 2  16 000 x 1

d (Tot. Surface Area / Buit. Oppervlakte)


 2 x 16000 x  2  derivative/ afgeleide A
dx

S A
16 000
 2x 
x2  equating derivative to/ stel
afgeleide aan 0 A
2 x 3  16 000  0
x 3  8 000  value of/ waarde van x
x  20 cm CA
4 000  value of/waarde van h
h 10
(20) 2 CA
NPU
(5)
[8]
Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief
Technical Mathematics/P1/Tegniese Wiskunde/V1 20 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

QUESTION/VRAAG 9

 x x 
 6 x dx
2
9.1.1

  x 3
 6 x dx 2
S A

x4 x4
  2x 3  C  CA
4 4
 2x 3 CA
 C A
(4)
 1
  3   dx
x
9.1.2
x
x 3x
3  A
  ln x  C ln 3
ln 3
 ln x  C A
(2)
4  M Area notation using
9.2 A  g ( x) dx
k integrals/ Area-notasie met
4 gebruik van integrale A
#   3x 2 dx
k

 x3  4
k
x3 A

 ( 4) 3  (k ) 3  SF CA
 ( 4) 3  (k ) 3  56  equating area to/ stel
oppervl gelyk aan 56 CA
k 3  8 S CA
k  2 value of / waarde van k CA

OR/OF OR/OF
4
A  0
g ( x) dx  M Area notation using
4 integrals/ Area-notasie met
 3x 2 dx gebruik van integrale A
0

 x3  4
0 x3 A
 SF CA
 ( 4)  (0)  64 3 3

2
A  0
g ( x) dx

 x3  2
0

 ( 2) 3  (0) 3  8 S CA
 64  8  56 M CA
k  2 value of / waarde van k CA

OR/OF
OR/OF

Copyright reserved/Kopiereg voorbehou Please turn over/Blaai om asseblief


Technical Mathematics/P1/Tegniese Wiskunde/V1 21 DBE/November 2021
NSC/NSS – Marking Guidelines/Nasienriglyne

Trial & Error Method/ Probeer en Trefmetode


4 Area notation using
A k
g ( x) dx integrals/ Area-notasie met
4 gebruik van integrale M
  3x 2 dx
k
x3
x 3 4
k A

Let/Laat k = 1
M CA
 x3  4
1

 ( 4) 3  (1) 3  SF CA
 63
Let/Laat k = 2
 x3  4
2

 ( 4) 3  (2) 3
 56  S CA
k  2 value of / waarde van k CA

(7)
[13]
TOTAL/TOTAAL: 150

Copyright reserved/Kopiereg voorbehou

You might also like