Professional Documents
Culture Documents
FW Anilox + Cleaner C1 - ENG - 20151916
FW Anilox + Cleaner C1 - ENG - 20151916
Product identifier
Relevant identified uses of the substance or mixture and uses advised against
Relevant identified uses of the substance or mixture
Cleaner for solvent based-/UV and water based inks.
Washing and Cleaning Products (including solvent based products) (PC 35)
Manufacturer/Supplier:
Flexo Wash ApS
Grenåvej 631K
8541 Skødstrup
Denmark
Tel./ Fax: + 45 86993631 / 86991343
E-Mail: info@flexowash.com
2. Hazards identification
Flexo Wash ApS . Grenåvej 631 K . 8541 Skødstrup . Denmark . T: +45 86 99 36 31. F: +45 86 99 13 43 . info@flexowash.com . www.flexowash.com
Label elements
Hazard pictogram(s)
Signal word
Warning
Hazard statement(s)
Causes serious eye irritation. (H319)
Causes skin irritation. (H315)
Safety statement(s)
General
If medical advice is needed, have product container or label at hand. (P101).
Keep out of reach of children. (P102).
Prevention
Wear protective gloves/protective clothing. (P280).
Response
IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and
easy to do. Continue rinsing. (P305+P351+P338).
If eye irritation persists: Get medical advice/attention. (P337+P313).
Storage
-
Disposal
-
Identity of the substances primarily responsible for the major health hazards
-
Other hazards
Additional labelling
-
Additional warnings
VOC
-
Flexo Wash ApS . Grenåvej 631 K . 8541 Skødstrup . Denmark . T: +45 86 99 36 31. F: +45 86 99 13 43 . info@flexowash.com . www.flexowash.com
3. Composition/information on ingredients
Substances/Mixtures
(*) See full text of H-phrases in chapter 16. Occupational exposure limits are listed in section 8, if these
are available.
Other informations
Detergent:
General information
In the case of accident: Contact a doctor or casualty department – take the label or this safety data
sheet. Contact a doctor, if in doubt about the injured person’s condition or if the symptoms continue.
Never give an unconscious person water or similar.
Inhalation
Get the injured person into fresh air. Make sure there is always someone with the injured person.
Prevent shock by keeping the injured person warm and calm. If the person stops breathing, give
mouth-to-mouth resuscitation. If unconscious, roll the injured person onto side with the top leg bent at
both knee and hip. Call an ambulance.
Skin contact
Remove contaminated clothing and shoes at once. Skin that has come in contact with the material
must be washed thoroughly with water and soap. Skin cleanser can be used. DO NOT use solvents or
thinners.
Eye contact
Remove contact lenses. Flush eyes with water (20-30°C) for at least 15 minutes. Call a doctor.
Ingestion
Give the person plenty to drink and stay with the person. If the person feels unwell, contact a doctor
immediately and take this safety data sheet or the label from the product with you. Do not induce
vomiting unless recommended by the doctor. Hold head facing down so that no vomit runs back into
the mouth and throat.
Burns
Not applicable
Information to medics
Bring this safety data sheet.
Flexo Wash ApS . Grenåvej 631 K . 8541 Skødstrup . Denmark . T: +45 86 99 36 31. F: +45 86 99 13 43 . info@flexowash.com . www.flexowash.com
5. Fire-fighting measures
Extinguishing media
Recommended: alcohol-resistant foam, carbonic acid, powder, water mist. Water jets should not be
used, since they can spread the fire.
Special hazards arising from the substance or mixture
No special
Environmental precautions
No specific requirements.
Control parameters
OEL
sodium hydroxide caustic soda (EH40/2005)
Long-term exposure limit (8-hour TWA reference period): - ppm | - mg/m3
Short-term exposure limit (15-minute reference period): - ppm | 2 mg/m3
DNEL / PNEC
No data available.
Exposure controls
Compliance with the stated exposure limits values should be checked on a regular basis.
Flexo Wash ApS . Grenåvej 631 K . 8541 Skødstrup . Denmark . T: +45 86 99 36 31. F: +45 86 99 13 43 . info@flexowash.com . www.flexowash.com
General recommendations
Observe general occupational hygiene.
Exposure scenarios
If there is an appendix to this safety data sheet, the indicated exposure scenarios must be complied.
Exposure limits
Trade users are covered by the rules of the working environment legislation on maximum
concentrations for exposure. See work hygiene threshold values below.
Hygiene measures
Whenever you take a break in using this product and when you have finished using it, all exposed
areas of the body must be washed. Always wash hands, forearms and face.
Generally
Use only CE marked protective equipment.
Respiratory Equipment
Recommended: In case of spray application: Use mask with particle filter S/SL, P2, White
Skin protection
Special work clothing should be used.
Hand protection
Recommended: Nitrile rubber. . : NA
Eye protection
Use safety glasses with a side shield.
Phase changes
Melting point (°C) Boiling point (°C) Vapour pressure (mm Hg)
- -
Data on fire and explosion hazards
Flashpoint (°C) Ignition (°C) Self ignition (°C)
- - -
Flexo Wash ApS . Grenåvej 631 K . 8541 Skødstrup . Denmark . T: +45 86 99 36 31. F: +45 86 99 13 43 . info@flexowash.com . www.flexowash.com
Explosion limits (Vol %) Oxidizing properties
- -
Solubility
Solubility in water n-octanol/water coefficient
Soluble -
Other information
Solubility in fat Additional information
- N/A
Reactivity
No data available
Chemical stability
The product is stable under the conditions, noted in the section on “Handling and storage”.
Conditions to avoid
Do not expose to heat (e.g. sunlight), because it can lead to excess pressure.
Incompatible materials
Strong acids, strong bases, strong oxidizing agents, and strong reductants agents.
Acute toxicity
Substance Species Test Route of exposure Result
sodium hydroxide caustic sod... Rabbit LD50 Oral 325 mg/kg
sodium hydroxide caustic sod... Mouse LD50 Intraperitoneal 40 mg/kg
Skin corrosion/irritation
Causes skin irritation.
Carcinogenicity
No data available.
Reproductive toxicity
No data available.
Flexo Wash ApS . Grenåvej 631 K . 8541 Skødstrup . Denmark . T: +45 86 99 36 31. F: +45 86 99 13 43 . info@flexowash.com . www.flexowash.com
STOT-single exposure
No data available.
STOT-repeated exposure
No data available.
Aspiration hazard
No data available.
Toxicity
Substance Species Test Test duration Result
sodium hydroxide caustic sod... Crustacean EC50 48 h 40380 μg/L
sodium hydroxide caustic sod... Fish LC50 96 h 125 mg/L
Bioaccumulative potential
Substance Potential bioaccumulation LogPow BFC
sodium hydroxide caustic sod... No No data available No data available
Mobility in soil
No data available
Waste
EWC code
20 01 29
Specific labelling
-
Contaminated packing
Packaging which contains leftovers from the product must be disposed of in the same way as the
product.
Flexo Wash ApS . Grenåvej 631 K . 8541 Skødstrup . Denmark . T: +45 86 99 36 31. F: +45 86 99 13 43 . info@flexowash.com . www.flexowash.com
14. Transport information
Not listed as dangerous goods under ADR, IMDG and IATA regulations.
ADR/RID
UN number
UN proper shipping name
Transport hazard class(es)
Packing group
Notes
Tunnel restriction code
IMDG
UN-no.
Proper Shipping Name
Class
PG*
EmS
MP**
Hazardous constituent
IATA/ICAO
UN-no.
Proper Shipping Name
Class
PG*
Environmental hazards
-
Safety, health and environmental regulations/legislation specific for the substance or mixture
Additional information
Sources
Regulation (EC) No 648/2004 of the European Parliament and of the Council of 31 March 2004 on
detergents.
EC Regulation 1272/2008 (CLP).
EC regulation 1907/2006 (REACH).
Flexo Wash ApS . Grenåvej 631 K . 8541 Skødstrup . Denmark . T: +45 86 99 36 31. F: +45 86 99 13 43 . info@flexowash.com . www.flexowash.com
16. Other information
Other
It is recommended to hand over this safety data sheet to the actual user of the product. Information in
this safety data sheet cannot be used as a product specification.
The information in this safety data sheet applies only to this specific product (mentioned in section 1)
and is not necessarily correct for use with other chemicals/products.
A change (in proportion to the last essential change (first cipher in SDS version)) is marked with a blue
triangle.
Flexo Wash ApS . Grenåvej 631 K . 8541 Skødstrup . Denmark . T: +45 86 99 36 31. F: +45 86 99 13 43 . info@flexowash.com . www.flexowash.com