Professional Documents
Culture Documents
DSP Board & PWR Board Voltage Test Instructions
DSP Board & PWR Board Voltage Test Instructions
Please remove the DSP board and PWR board from the machine, remove the heat sink
on the DSP board, and remove the shield of the PWR board.As the figure shown.
Figure 1
Figure 2
Please find an ATX power supply and connect the 12V power cable to the PWR board,
as picture below:
Figure 3
Please assemble the DSP board and the PWR board, and use the ATX power supply to
supply power to the PWR board. As the figure shown.
Figure 4
Short-circuit the green and black cable in the 20 pins power cable of the ATX to start
up the ATX, as picture below:
Figure 5
Figure 6
Please measure the voltage on the DSP board and the PWR board separately. Please
refer to picture 1 and picture 2 for the specific location of the testing points. The
voltage measurement table is as follows.