Professional Documents
Culture Documents
Silicona Estructural Tremco
Silicona Estructural Tremco
Silicona Estructural Tremco
SG300
SILICONE SEALANT
Details of special substrates should be Modulus at 100% Elongation* EN ISO 8339 0.8-1.0 Mpa
submitted to tremco illbruck Production Sag 0mm
Technical Service Department for
Application Temperature +5°C to +35°C
recommendations.
Temperature Resistance -40°C to +150°C
A site adhesion trial is recommended to
*typical values
ensure substrate compatibility before
commencement of main installation.
Immediately remove all excess sealant Because the variety of material used, the
Method of Application: and smear adjacent to the joint with variety of application processes and the
Application should be in accordance one of above mentioned solvents (use variety of conditions of use are beyond
with BS 8000:16 - “Code of practice masking tape where appropriate). our control, preliminary tests are strongly
for sealing joints in buildings using recommended before any order.
sealants”. Cured sealant can only be removed by
The information and illustrations being
abrasion.
reproduced on this document are based on
All beads should be tooled immediately
Compliance and Approvals features in progress and on our experience
after application to ensure firm, full
SG300 Spectrem 2 meets the at the time of May 2015.
contact with join face.
requirements of EN ISO 11600 G&F
The manufacturer reserves the right of
25HM.
Use a conventional skeleton gun. modifying the technical characteristics of its
The product is compliant with EN products at any time.
Coverage Rate:
15651-1 and EN 15651-2.
To determine quantity of sealant required, The warranty policy of these products is
calculate as follows: The product has the CE marking. exclusively governed by our general terms
and conditions of sales.
Safety Precautions
Gap Total
The Technical and Safety Data Sheets must tremco illbruck can not be held liable based
Width x Depth x Length N° of
be read and understood before the use. on the general information given by this
(cm) (cm) (cm) = cartridges
document.
SG300/100 – Etat des données 05/2015
310ml Service
Our team of technicians remains at your
For further guidance on application disposal for further information.
methods, and materials requirements,
Note
please contact tremco illbruck Technical The information in this document is provided
Service Department for informational purposes and are non-
Cleaning: binding. Technical data are not expressly
Cleaning of all tools can be accomplished warranted characteristics of the goods.
with solvents such as Isopropanol or
Methyl Ethyl Ketone (MEK).