Professional Documents
Culture Documents
Jsa For Insulation Inside Stripper.
Jsa For Insulation Inside Stripper.
Jsa For Insulation Inside Stripper.
Now undertake the JSA and record in the table below. Use prompts on JSA Prompt Sheet and Hazard Checklist PA-HSEC-02-040-002-F03.
Part 3: Contingency Plans. Standard PPE, S: First aid kit must be present at the area and the Hse personnel are the first response in case of
emergency. Man lift must be present all the time. Safety Observer is responsible to check the time.
Part 4: Review. After the job has been completed, JSA leader should note: any hazards, which were identified in the original JSA? Any practices
that need to be captured in the OMS? List action items, changes, and transfer any changes to the Change Management system.
File: 10.30
JSA No: JOB TITLE:
Step Describe Job Step Potential Hazards Hazard Controls
No (Copy from part 2 of form) (Use Hazard Checklist)
1 Mobilization of workers & Unauthorized equipment/tools brought out to Before mobilization any equipment/ tools make
equipment site sure that the E & P Personal got inspected. Ensure
that the checklist is with every equipment.
Unskilled and uninducted personal starting the Ensure that all personal prior to start the work
job should be inducted and oriented about the hazards
in the job site
Workers starting the job unfit to work All persons not fit to work shall not be allowed to
work at the project site.
Work without JSA/Confined Space Permit JSA & Confined Space permit must be placed
prior to work
Ensure all the persons take part in the tool box
meeting discussion
2 Entering the hole (Dia 20 inch) Improper access Prior to work make arrangement proper access to
enter the hole dia 20 inch
Unskilled and untrained and physically unfit Skilled trained and physically fit person enter the
person enter the confined space confined space
He should be aware all related confined space
hazards
Head and body injury Use the right method while entering in confined
space/man hole
Get sport /help from safety observer if required
while entering.
Ensure that when a person going into the
Confined space must worn the chin strap.
JSA No: JOB TITLE:
Step Describe Job Step Potential Hazards Hazard Controls
No (Copy from part 2 of form) (Use Hazard Checklist)
Improper PPE’s Ensure that PPE’s shall be worn at all times like
hand gloves, safety helmet with chain strip, safety
goggles and coveralls
Poor Ventilation Ensure that the fans are must be in place for
proper ventilation of air and also Air compressor
must be use for fresh air
Entering without body harness Ensure that the entrant must be used the full body
harness and hook off body harness with the
lifeline.
Left the position of attendant Ensure the attendant or watch man must be
present all time in front of main hole and he will
maintain confined space entry register
Deficiency / Excess of Oxygen Confined space coordinator must be monitor
every 30 minutes with gas detector
Confined space coordinator must ensure that the
oxygen limit is in between (19.5 to 21.5 %)
Poor lighting Sufficient illumination must be installed inside the
cold box. This lighting voltage must be 110 v or
less.
Poor communication Safety observer should remain at entering point
throught the activity in confined space