Manual de Usuario Whirlpool ADP 6600 WH (8 Páginas)

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 2

Quick reference guide Chart

BEFORE USING THE APPLIANCE FOR THE FIRST TIME CAREFULLY READ
THIS QUICK REFERENCE GUIDE AND THE ASSEMBLY INSTRUCTIONS!

THE CONTROL PANEL OF THIS DISHWASHER ACTIVATES PUSHING


ANY BUTTON EXCEPT CANCEL/OFF BUTTON.
FOR ENERGY SAVING THE CONTROL PANEL DEACTIVATES
AUTOMATICALLY AFTER 30 SECONDS IF NO CYCLE HAS STARTED.

Options and display description


(see at right for options description)
PROGRAMS SELECTION START/RESUME BUTTON CANCEL/OFF BUTTON SALT INDICATOR RINSE AID INDICATOR
BUTTON Push this button to start the selected program: the Push this button to switch off the control panel. When lit (at the end of the cycle), When lit (at the end of the cycle),
the salt reservoir needs to be the rinse aid dispenser needs to
Push “Programs” button indicator lights up and goes off at the end of the If pressed when a program is running it cancels the
refilled. be refilled.
(repeatedly) until the indicator program. When the door is opened during a program ongoing draining water for 1 minute
of the required program lights washing cycle, the cycle is temporarily paused: the (0:01 is shown into the display).
up (see “Table of programs” Start indicator blinks. To resume the cycle close If pressed when the dishwasher is switched off, it
below). the door and push Start button again. drains any possible liquids from dishwasher WASH TIME DISPLAY
(1minute process). Indicated the cycle duration and the remaining time (h:min). With “Delayed start” selected it indicates
the time remaining until program start (h.00) - below 1h (0:mim).
If “Fx Ey” messages appears on the display, see page 6 - chapter “What to do if...”.
Table of programs Consumption
Deter- MULTIZONE
Available gent Litres kWh
P Programs
options
Loading instructions Minutes 1)
Allows you to choose the washing
zones. Press this button (repeatedly)
to select the wash zones:
Delay
both racks
1 AutoSensor 50-65°C Multizone Recommended program for routine washes,
Antibacterial with dried-on food (e.g. EN 50242).
X 7-14 1.00-1.60 70-155
rinse
only lower rack
2 Pre-Wash cold Delay
Multizone
Crockery to be washed later. — 4.0 0.03 14
only upper rack

- indicator lits
3 Glasses 40°C Delay
Multizone
Light soiling, for example glasses and cups. X 10.0 0.85 100 TABLET SETTING DELAYED START
This setting allows to BUTTON
ANTIBACTERIAL RINSE 3) optimize the cycle Push the button
performances according (repeatedly) to delay the
4 Quickwash 45°C Delay
Multizone
Lightly soiled crockery, with no dried-on
food.
X 11.0 0.80 30 This function activates an
antibacterial rinse at the end of the the type of detergent start of the program.
wash cycle, guaranteeing a further used. Push the Tablet Adjustable from 1 to 24
Delay reduction of bacteria. Press the button for 3 seconds (until
the indicator lights up) if hours. With each press of
5 Eco 2) 50°C Multizone
Antibacterial
Normally soiled crockery. X 12.0 1.05 150 button to activate or deactivate the
function. This function can be used you are using the the button, the delayed
rinse with the programs indicated in the combined detergents in start indicator increases
Delay table of programs. The dishwasher tablet (rinse aid, salt and by one hour and after 24
Recommended program for heavily soiled detergent in 1 dose). If you
6 Intensive 70°C Multizone
crockery, especially suitable for pans and
Antibacterial saucepans.
X 14.0 1.55 155
door must be kept shut for the entire
duration of the program in order to are using powder
restarts from 0. Then
press the START button.
rinse guarantee reduction of bacteria. If detergent or liquid
detergent, the Tablet The dishwasher will start
1) Program data obtained in conformity with European standard EN 50242, obtained under normal conditions (without additional the door is opened the indicator lamp
starts flashing. indicator on the control after the set time.
options) and may vary depending on conditions. Differences of up to 20 minutes are possible with sensor programs as a result of the panel has to be off.
appliance’s automatic calibration system.
2) Reference program for energy label in compliance with EN 50242 regulations. - Note for Testing Institutes: for detailed information on the
EN/Standard loading comparison test and other tests, contact the following address: “nk_customer@whirlpool.com”.
3) The antibacterial action has been tested by the Institut Pasteur of Lille (France), based on the NF EN 13697 standard of November 2001. ADP 6600 5019 396 01900
GB -1-

You might also like