Professional Documents
Culture Documents
Estweld MSDS
Estweld MSDS
: ICTS2020508MOE/255
Address: : No.2 Cao Di, Zhong Jia Sha County, Wu Xiang Town,
Yinzhou District, Ningbo
For guidance on selection of personal protective equipment see Chapter 8 of this Material Safety Data Sheet. See
Chapter 13 for information on disposal. Observe the relevant local and international regulations.
Personal precautions, protective Ensure adequate ventilation. Use personal protective equipment..Avoid
equipment and emergency dust formation.
procedures:
Environmental precautions: Do not discharge into the environment. See section 12 for more ecological
information. Prevent spills from contaminating the groundwater system.
Appearance : Particles.
Color: Gray-black.
Shanghai ICTS Inspection Center, Ltd
Tel: +86-21-60345500
Fax: +86-21-60919230
E-mail: info@ictsgroup.cn
Web: www.ictsgroup.cn 5/9
Report No.: ICTS2020508MOE/255
Odor: Odorless.
Odor threshold: Not applicable.
Molecular weight: Not applicable.
Molecular formula: Not applicable.
Molar mass: Not applicable.
PH: Not applicable.
Density: Not applicable.
Melting point/range (°C): Not applicable.
Boiling point (°C): Not applicable.
Solidification point: Not applicable.
Flash point: Not applicable.
Auto-ignition temperature: Not applicable.
Ignition temperature: Not applicable.
Ignition point: Not applicable.
Flammability: Not applicable.
Upper/lower flammability or Not applicable.
explosion limit:
Decomposition temperature: Not applicable.
Relative density(Water=1): Not applicable.
Relative density(Air=1): Not applicable.
Volume density: Not applicable.
Solubility: Not applicable.
Vapor pressure: Not applicable.
Vapor density: Not applicable.
Volatilization rate: Not applicable.
Viscosity: Not applicable.
Solid content: Not applicable.
Stability: The product is stable when stored and used under normal ambient
temperature.
Reaction: Under normal conditions it won't happen.
Conditions to be avoided: No data available.
Incompatibility: Strong oxidant.
Decomposition products: Silicon dioxide. Copper oxide
Waste treatment methods Please refer to the requirements of relevant laws and regulations of
your country or region before disposal.
Packaging: Please refer to the requirements of relevant laws and regulations of
your country or region before disposal.
GHS Labelling Elements: Classification and labelling are carried out according to the Globally Harmonized
System of Classification and Labelling of Chemicals (GHS).
This MSDS was prepared sincerely on the basis of the information we could obtained, however, any warranty shall not be
given regarding the data contained and the assessment of hazards and toxicity. Prior to use, please investigate not only the
hazards and toxicity information but also the laws and regulations of the organization, area and country where the products are
to be used, which shall be given the first priority. Products are supposed to be used promptly after purchase in consideration of
safety. Some new information or amendments may be added afterwards. If the products are to be used far behind the expected
time of use or you have any questions, please feel free to contact us. The stated cautions are for normal handling only. In case
of special handling, sufficient care should be taken, in addition to the safety measures suitable for the situation. All chemical
products should be treated with the recognition of "having unknown hazards and toxicity", which differ greatly depending on
the conditions and handling when in use and/or the conditions and duration of storage. The products must be handled only by
those who are familiar with specialized knowledge and have experience or under the guidance of those specialists throughout
use from opening to storage and disposal. Safe usage conditions shall be set up on each
user’s own responsibility.
END OF REPORT.