Professional Documents
Culture Documents
115NZ NZC
115NZ NZC
com
1. Features
Characteristics
Materials Cleaning
Inner core: Galvanized steel (standard) or stainless steel Nozzle: Multi jet nozzle G3/8
V4A (1.4571/AISI 316) Cleaning pres-
End caps: Galvanized steel (standard) or stainless steel sure: 6 bar (max. 7 bar)
V4A (1.4571/AISI 316) Differential pres-
Seal: self-adhesive needle felt sure: max. 18 mbar
Filter media: Ti 07 - Electrically conductive polyester fleece Compressed air
with PTFE membrane consumption per
Ti 08 - Electrically conductive polyester fleece cleaning pulse: 9 l (fad)
Ti 15 - Polyester fleece Compressed air
other media on request reservoir capacity: max. 2 l per filter cartridge/cleaning pulse
Technical data is subject to change without notice!
4. Installation
4.1 Raw gas side installation 4.2 Clean gas side installation
The dust filter cartridge can be mounted on and dismantled from the The dust filter cartridge is fastened to the filter plate on the cleaned
filter plate using the Rd 60x4 thread adapter - no tools required (tight- side by use of holding down clamps. The cartridge will be put from
ening torque max. 15 Nm). A hole with a diameter of 67 mm must the clean gas side through the hole in the filter plate into the raw gas
be drilled in the filter plate in order to mount the thread adapter. The side. To protect the pleats against the filter plate, there is a metal
thread adapter should be spot-welded to the filter plate as shown ring (approx. 16 mm high) glued into the end cap. We recommend
in the drawing. Various adapters are available for installation on the cleaning the dust filter cartridge with the MAHLE multi-jet nozzle. Re-
cleaned side or for mating with Rd 72x5 or Rd 74x4 round threads. commended diameter of the hole in the filter plate for clean gas side
mounting is 118 mm.
LEER
6. Cleaning
LEER
We recommend cleaning the dust filter cartridge with the Filtration
Group multi-jet nozzle. The optimized geometry of the multi-jet nozzle
guarantees excellent cleaning results with a significantly lower noise
level.
The multi-jet nozzle is available from Filtration Group in aluminium or
stainless steel. It can also be purchased as part of the Filtration Group
MJD cleaning unit, comprising the nozzle, a stirrup and various small
assembly components. The stirrup maintains an optimum distance
from the cartridge to ensure maximum cleaning efficiency.
7. Design
Please contact us for detailed technical information, any open questions and for general expert advice. Completion of the relevant questionnaire
would facilitate in the coordination of all important parameters.
Comprehensive documentation on our product range, cleaning units and cartridges can be provided.
LEER
LEER
LEER
LEER
LEER
LEER
LEER
LEER
Filtration Group GmbH
Schleifbachweg 45
D-74613 Öhringen
Phone +49 7941 6466-0
Fax +49 7941 6466-429
sales@filtrationgroup.com
www.filtrationgroup.com
70562981.11/2016