Professional Documents
Culture Documents
Course: Boeing 777-200/200er/300/300er B1 - Phase 10 - Av Ext
Course: Boeing 777-200/200er/300/300er B1 - Phase 10 - Av Ext
Required TOPIC Subject Level No. of Actual No of No. of Question Numbers selected
Subject Duration Questions Questions in Questions
Level required in the bank to be
the bank picked
2 ATC/TCAS 2 1 4 0
2 5 3
3 3 0
TOTAL 12 3
2 WEATHER RADAR 1 1 4 0
2 7 2
3 1 0
TOTAL 12 2
2 FLIGHT INTERPHONE/ 2 1 8 0
SERVICE INTERPHONE/ 2 10 3
GROUND CREW CALL 3 0 0
TOTAL 18 3
2 VHF/HF 2 1 4 0
2 8 2
3 1 0
TOTAL 13 3
2 SELCAL/ELT 2 1 4 0
2 5 2
3 0 0
TOTAL 9 2
2 CABIN INTERPHONE 2 1 0 0
2 5 2
3 0 0
TOTAL 5 2
Required TOPIC Subject Level No. of Actual No of No. of Question Numbers selected
Subject Duration Questions Questions in Questions
Level required in the bank to be
the bank picked
2 PAS/ SATCOM/DCMF/EFB/ 5 1 16 2
FDEVSS/CVR/PC PWR 2 12 5
3 2 0
TOTAL 30 7
2 IFE (MAS 2000E) 5 1 8 1
2 16 4
3 0 0
TOTAL 24 5
2 IFE (MAS 3000I) 3 1 8 0
2 8 3
3 0 0
TOTAL 16 3
TOTAL 139 30
I hereby confirm that the question levels selected for the examination meet the requirements of EASA Part 66 Appendix 3.
PHASE - X
MASTER
ATA 34 – ATC/TCAS
a] a ground station
b] an airborne system
c] a part of TMCS - in full not abbreviated
L1 Q.4 The TCAS helps the flight crew and air traffic control to:
a] the top antenna is connected to the Left ATC, the bottom antenna to the Right
ATC
b] both antennas are connected to the selected ATC
c] the top antenna is connected to both ATC’s and the bottom antenna is in
standby.
L2 Q.6 The ATC/Mode S Transponder supplies a 24 bit unique airplane identification code to:
a] SELCAL decoder
b] flight deck displays (PFDs)
c] TCAS computer
L2 Q.9 Suppression signals are sent from the DME Interrogator to the:
L3 Q.10 All tests for the ATC/mode S transponder must be done from the:
a] MCDU
b] MAT or a PMAT
c] ATC/TCAS Control panel
L3 Q.11 What happens to TCAS AUDIO ADVISORIES when there is a Ground Proximity
Warning System warning or alert?
a] weather conditions
b] land contours
c] weather conditions and land contours
L1 Q.2 The Weather radar returns show in four different colors on the:
a] ND only
b] PFD only
c] EICAS only
L2 Q.5 Before commencing maintenance on the Weather radar antenna assy, what precaution
should you observe?
a] either of the Weather radar pushbutton to ‘ON’ at the EFIS control panels
b] the ‘Test’ position only
c] only by the left or right RT pushbutton on the pedestal
L2 Q.7 The Weather display on the ND is indicated when the ND mode switch is:
a] above 800ft
b] below 2300ft
c] above 2300ft
L2 Q.9 A predictive windshear symbol is displayed on the ND if PWS is detected and the
aircraft is:
L2 Q.10 The Weather radar antenna SCAN and ELEVATION disable switches when selected to
OFF will stop:
L2 Q.11 What range does the Weather radar turbulence mode have?
a] 40NM
b] 80NM
c] it’s variable depending on the selection
L3 Q.12 The purpose of the LANDING GEAR lever module signal to the PWS is:
L1 Q.1 The flight crew uses the flight interphone system to speak:
L1 Q.2 Which unit controls the routing of audio signals to and from the flight crew for the flight
interphone system?
L1 Q.3 The ground crew uses the service interphone system to talk:
a] to each other
b] to the flight crew
c] to each other and to the flight crew
a] in the cabin
b] on the flight deck
c] in the main equipment center
L1 Q.6 The ground crew call horn and the service and APU shutdown panel are in the:
a] cockpit
b] nose wheel well area.
c] main equipment center
L1 Q.7 The ground crew pushes the flight deck call switch on the service and APU shutdown
panel to call the:
a] flight deck
b] cabin attendants
c] other ground crew and cabin attendants
L1 Q.8 To initiate a ground crew call from the flight deck, selection is made from the:
L2 Q.9 What is the function of the observer audio selector switch on the centre pedestal?
a] it allows the first officer to use the captain’s station card in the audio management
unit
b] it allows the captain or first officer to use the first observer’s station card in the
Audio Management Unit
c] it allows the first observer to use the captain’s or first officer’s station card in the
Audio Management Unit
L2 Q.11 The left and right flight interphone speaker volume is controlled from:
L2 Q.13 The purpose of the service interphone switch on the overhead panel P5 is to connect
the:
a] one group
b] two groups
c] three groups
L2 Q.17 The flight crew and the ground crew use the ground crew call system to tell each other
to answer a call on the:
L2 Q.18 The Ground Crew Call system supplies aural and visual signals:
L1 Q.1 Which VHF Radio can provide data communications from the flight deck?
a] left
b] left and right
c] centre or right
L1 Q.3 Which component do you use to select the frequency for VHF communication?
a] ceiling compartment
b] nose radome
c] vertical stabilizer
L2 Q.5 Which VHF system will be powered with only Battery power available?
L2 Q.6 The VHF communication system permits voice and data communication over:
L2 Q.9 If a HF antenna coupler ‘FAULT’ is reported, which of these could be the most probable
cause?
L2 Q.10 On the HF transceiver, the LRU FAIL indicator light comes on for:
a] ground waves
b] sky waves
c] microwaves
L2 Q.12 On the HF system, pressurization is through the pressure valve on the front of the:
a] coupler
b] antenna
c] transceiver
a] tells the ground crew that there is a call from the aircraft on a communication
transceiver
b] tells the flight crew that there is a call from a ground station on a navigation
receiver
c] tells the flight crew that there is a call from a ground station on a communication
transceiver
L1 Q.3 Which system automatically sends emergency signals when it senses a large change in the
airplane velocity?
L1 Q.4 The emergency locator transmitter control panel is in the flight deck on the:
a] overhead panel.
b] aisle stand panel
c] captain side panel
L2 Q.5 The Flight Crew identifies a SELCAL message in the cockpit by:
L2 Q.7 The ‘Call’ light on any VHF pushbutton on the ACP illuminates for:
a] SELCAL
b] data link
c] cabin interphone call
L2 Q.8 The SELCAL decoder is:
a] connects to the SELCAL control panel and displays the SELCAL code on the
instrument panel
b] connects to the SELCAL decoder and gives each airplane its SELCAL code
c] monitors for audio tones
ATA 23 – CABIN INTERPHONE
L2 Q.2 If the normal Cabin Interphone Controller fails, alternate selection is made from the:
L2 Q.3 If there is a problem with the cabin interphone system, how can you quickly determine if
the problem is in the passenger address/cabin interphone controller or not:
L2 Q.4 To make a call to the cabin attendants from the cockpit using the boom mic:
a] push the FLT transmit switch on the ACP. Then use the centre CDU to select a
dial code
b] push the CAB transmit switch on the ACP. Then use the centre CDU to select a
dial code
c] transfer the SERV INT toggle switch on P5 to ‘ON’
a] PA/CI controller
b] AIMS cabinets
c] Warning Electronics Unit
ATA 23 – PAS/SATCOM/DCMF/EFB/FDEVSS/CVR/PC PWR
L1 Q.2 Which system receives audio inputs and sends them to the passenger cabin?
L1 Q.3 Which type of passenger address announcement has the least priority?
a] glareshield
b] overhead panel
c] aisle stand panel
L1 Q.8 Which VHF systems provide the data link facility?
L1 Q.9 Which reference lets the flight crew access to the electronic flight operation data,
general purpose computing and communications:
L1 Q.11 On the B777-300ER aircraft, the Camera Interface Unit is located in the:
a] cockpit
b] forward electronics compartment
ü c] forward galley area
L1 Q.12 On the B777-300ER aircraft, the video display from the 3 cameras is viewed on the:
a] MFD
ü b] EFB display unit
c] ND
L1 Q.14 How many minutes of audio does the cockpit voice recorder system keep?
a] 60
b] 120
c] 180
L1 Q.15 The PC Power System is a 110 VAC/60Hz power system that supplies power for:
a] personal computers
b] hair dryers or shavers
c] laptop computers or other passenger electronic devices
L2 Q.17 Which type of passenger address announcement has the highest priority?
L2 Q.18 In each zone how many columns of Speaker Drive modules are there?
a] 2
b] 3
c] 1
a] 3 speakers
b] 4 speakers
c] 2 speakers
L2 Q.20 Which component in the SATCOM system contains system operation software and
position/ frequency data for each satellite?
L2 Q.25 On the Electronic Flight Bag system, Electronic Units send display data to their on-side
Display Units on:
L2 Q.26 Which components are in the main equipment center that interface with the Electronic
Flight Bag?
L2 Q.27 On B777-300ER aircraft, the power supply to the 3 Video cameras is:
a] 115V AC
ü b] 12V DC from the camera interface unit
c] 28V DC from EFB electronics unit
L2 Q.28 The Flight Deck Entry Video Surveillance System (FDEVSS) is a video system that
provides the flight crew surveillance capability of the:
L3 Q.30 On the B777-300ER Electronic Flight bag main menu page, if the “Initialize Flight’ button
is selected:
L1 Q.1 In the MAS 2000e system, the Cabin Crew controls and monitors system functions from
the:
L1 Q.2 In the MAS 2000e system, overhead video components (Projectors and Monitors) are
located in the:
a] cockpit overhead
b] overhead and galleys
c] overhead and throughout the cabin
L1 Q.3 In the MAS 2000e system, which handset is used to control and indicate the selection of
video programs, including Airshow, to be viewed on the Seat Display Unit?
L1 Q.4 Which MAS 2000e component provides all operational controls for the Audio and Video
(Overhead and In-Seat) networks and for all maintenance functions?
L1 Q.5 In the MAS 2000e system, the number of external video cameras that provide video to
the System 2000e:
a] two
b] three
c] four
L2 Q. 9 In the MAS 2000e system, which LRUs are connected to the LAN HUB?
L2 Q.10 In the MAS 2000e system, Which LRUs are distribution types?
L2 Q.11 In the MAS 2000e system, Which LRUs are seat LRU types?
a] 1
b] 4
c] 3
L2 Q.13 In the MAS 2000e system, Which LRUs are considered to be on the “core” LAN?
L2 Q.14 In the MAS 2000e system, which LRU is found in both the ‘core’ and ‘cabin’ LAN?
a] EVSCU
b] EPESC
c] CMEU II
L2 Q.15 In the MAS 2000e system, the airshow digital interface unit is responsible for:
L2 Q.16 In the MAS 2000e system, which LRU is in the seat LAN?
a] IVASEB
b] VMU
c] EVSCU
L2 Q.17 In the MAS 2000e system, what is the ‘primary’ purpose of the CMEU II?
L2 Q.18 In the MAS 2000e system, which interface card is used to connect the system 2000E
with the aircraft telephone system?
L2 Q.19 In the MAS 2000e system, what type of video signal is output from the VCPs?
a] RF video
b] baseband
c] digital
L2 Q.20 In the MAS 2000e system, which internal sensor will cause the VCP to be disabled?
a] video sensor
b] tape sensor
c] DEW sensor
a] in the VCC
b] inside the EPESC
c] in the EE-BAY
L2 Q.22 The primary purpose of the ZIU in the MAS 2000e system is to interface with:
a] Airshow
b] the aircraft systems
c] PSS
L2 Q.23 In the MAS 2000e system, if you have no PSS in First class what could cause this?
a] IVASEB
b] ZIU
c] EVSCU
L2 Q.24 In the MAS 2000e system, what happens to the token ring on the cabin LAN if EADB 3
loses power?
L1 Q.1 In the MAS 3000i system, In-seat entertainment equipment is installed in the:
L1 Q.2 In the MAS 3000i system, the Cabin Management Terminal is in the:
L1 Q.3 In the MAS 3000i system, the Cabin Telecommunication Unit is in the:
L1 Q.4 In the MAS 3000i system, the Enhanced Area Distribution Box is:
L1 Q.5 In the MAS 3000i system, audio and video on demand (AVOD) components are located in
the:
L1 Q.6 In the MAS 3000i system, at each seat, the passenger has the IFES audio, supplied to
the:
L1 Q.7 In the MAS 3000i system, the DVD Player is used for:
a] Audio/Video On Demand
b] Overhead Video
c] Software loading
L1 Q.8 In the MAS 3000i system, audio to the seats is normally from the:
a] VMU
b] tape reproducers of the avionics compartment
c] Hard Disk Drive Array
L2 Q.9 In the MAS 3000i system, the token ring interface with the CMT is via DSEB 1 and the:
L2 Q.10 In the MAS 3000i system, Audio and Video signals from the Hard Disk Drive Array to
the QAM Modulator Unit are transmitted using:
L2 Q.11 In the MAS 3000i system, selecting any one of the IFE Zone switches to OFF will
isolate power to its dedicated:
L2 Q.12 In the MAS 3000i system, overhead video is distributed from the Video Modulation Unit
via the RF Combiner-splitter/RF distribution Amplifier to the:
L2 Q.13 In the MAS 3000i system, the Audio/Video on Demand signals are sent to the Digital
Seat Electronic Box in:
a] MPEG format
b] Video RF and ADPCM audio format
c] RF QAM format
L2 Q.14 In the MAS 3000i system, Audio and Video On Demand signals are sent to the Digital
Seat Electronic Box via the:
a] 2
b] 3
c] 4
L2 Q.16 In the MAS 3000i system, the VCC supplemental cooling fan re-circulates the air from: