Professional Documents
Culture Documents
APR76802 EN r1 - Affinity 4 Labor Positioning - Poster LR
APR76802 EN r1 - Affinity 4 Labor Positioning - Poster LR
Labor Positions
The labor and delivery environment can be unpredictable for everyone involved.
Affinity® 4 bed helps deliver a safe, comfortable experience for mother, baby, and caregiver.
SITTING ON LABOR BALL THRONE POSITION: KNEELING OVER HEAD SEMI-FOWLERS WITH
Rocking back and forth while
“C-CURVE” OF THE BED CALF SUPPORTS
sitting on the labor ball decreases While in the throne position, the Kneeling is an alternate position for If the mother has an epidural, she
pain, promotes relaxation, opens mother can lean forward to allow the mothers who are unable to use the can be placed in a high Semi-Fowlers
transverse and anterior-posterior baby and uterus to fall forward in the squatting position, or who experience position with her legs in the calf
pelvic diameters while facilitating abdomen. She can also be directed by back pain. supports to labor down.
fetal descent. the contractions toward the posterior
This position provides easy access to When the baby’s head has crowned
For safe use, the patient should part of the pelvic inlet.
a mother’s lower back for massage or and the birth is imminent, the mother
always hold onto something in front The mother’s back looks like the letter hot/cold compresses. can then begin to push.
of her and have a support person “C.” This position can be used with an Constant back pressure can be
sitting behind her. epidural for 30-45 minutes between
applied to the sacral area.
side-lying positions.
The mother can indicate where to
apply the pressure and how hard. If
the mother has had an epidural she
should be assessed to determine that
she can bear weight on her knees.
THE THRONE POSITION THRONE POSITION: SUPPORTED FULL SQUAT McROBERT’S POSITION
“C-CURVE” WITH WITH LABOR BAR
The throne position is achieved by In the instance of a shoulder dystocia,
LABOR BALL
completely raising the back of the bed If the mother does not have an McRobert’s position can be quickly
up and lowering the foot section. Using a labor ball is another way to epidural or has a low-dose epidural accomplished by placing the mother
position the mother in a “C- curve.” that enables her to support herself flat by pulling the CPR lever; and
It can be used intermittently with
This technique also increases with her legs, she can get into a full raising the foot section of the bed.
mothers who have epidural anesthesia.
the utero-spinal drive angle while squat position on the foot section of Place the soles of her feet against the
This upright position makes use of directing the baby toward the the bed. back lip of the calf supports, this will
gravity to help the baby descend. posterior part of the pelvic inlet. Place
rotate the mother’s legs back against
The mother’s weight on her ischial the labor ball on the foot section of
her abdomen.
tuberosities helps to open the the bed and have the mother rock
transverse diameter of the pelvic back and forth on the ball.
outlet; the anterior-posterior diameter This rocking is usually comfortable for
can also open in this position. the mother and can facilitate descent
while being observed on continuous
fetal monitoring.
The smaller ball may be used if the
mother is large.
Hill-Rom reserves the right to make changes without notice in design, specifications and models. The only
warranty Hill-Rom makes is the express written warrantyextended on the sale or rental of its products.
© 2020 Hill-Rom Services, Inc. ALL RIGHTS RESERVED. APR76802 rev 1 28-APR-2020 ENG – US