Professional Documents
Culture Documents
XS-505-en TDS - PDF - 3
XS-505-en TDS - PDF - 3
XS- 505
effectively resist the shrinkage, deformation and
cracking of the base layer;
Scope of application
l It is applicable to waterproof treatment and
repair works of various roofs, ceilings, exterior
walls, etc.
Application process
l The base layer must be solid, flat, free of open water,
DESCRIPTION floating ash and oil, and the internal and external
This product is a water-based coating specially used for corners shall be made into arc corners. When the
roof exposed waterproofing, which is made of rubber metal roof is rusted or seriously damaged, the
emulsion as the base material, together with high- damaged base must be repaired, and special rust
grade resin emulsion, additives and fillers. This product conversion treatment agent shall be used for rust
resistance, acid and alkali resistance. It can be used l the pipe orifice, gutter, eave gutter, internal and
immediately after opening the barrel, and can be external corner nodes within the construction scope
exposed directly after construction, without protective shall be pre-coated and sealed, and the reinforcement
layer. It is especially suitable for waterproof treatment base material (mesh cloth, non-woven fabric) shall be
and waterproof repair works of the roof. paved during the coating process for reinforcement;
low temperature resistance, strong weather l in winter, the drying time should be extended before
resistance and long service life; the closed water test.
TECHNICAL SPECIFICATION
Standard: Q/SDK S 107 – 2022 Roof waterproof coating
1 Solid content/% ≥ 60
8
Heat treatment(80°C , 168h)
6
Elongation at break/% ≥ 150
Alkali treatment
Tensile strength retention/% ≥ 60
[0.1 %
7 NaOH+saturatedCa(OH) 2 Elongation at break/% ≥
solution, 168h] 150
l The temperature during construction shall be 5 °C- l The product is non-flammable nor explosive material, and
35 °C, no outdoor construction in windy or rainy and can be transported as general cargo. During transportation,
snowy days; it is not suitable to construct in a it should be protected from freezing, rain, solarization,
particularly humid and unventilated environment, extrusion and collision, and the packaging should be kept
l do not add water or diluent, otherwise the product l the product should be kept in dry and cool place at 5°C- 35