Professional Documents
Culture Documents
【Spec】BTS-PJ039B1 BOE Outdoor LED Cabinet 4000nits 3840Hz 500x1000mm SMD Series V2.0 20220811
【Spec】BTS-PJ039B1 BOE Outdoor LED Cabinet 4000nits 3840Hz 500x1000mm SMD Series V2.0 20220811
Key Feature
Without permission from BOE Technology Group Co., Ltd., any other
individual or organization shall not extract, reprint, copy, translate, edit, and
publish the specification in any form.
Pitch 3.91
Weight (kg/unit) 38
Operation
Waterproof Level IP66
Parameter
Product Picture
Installation
Square
steel
Block
Packing
Notes
Project Note
This product is for professional use only and does not support home use
In case of fire, electric shock and fall, this product has the risk of serious injury and death
Before installing, supplying, operating or maintaining this product, please read the instruction
manual carefully, understand the meaning of the symbols marked in the instruction manual
and on the product lock, and strictly follow the requirements listed in the safety precautions.
The product is only allowed to be connected to voltages in the range of 100V-240V and
frequencies in the range of 50-60Hz.
The ground of the product is always on, please disconnect the power when not working.
Before using the product, make sure that all equipment is in good condition.
Electric shock prevention
Do not modify the product in any way that is not described in the instruction manual.
Do not operate the product at full power in an external environment where the external
Fire prevention temperature is above 40°C or below -20°C.
Notes
Project Note
Whenever you install, maintain or move the product, close the work area or access.
Test that all external face shields and hardware are properly locked in place.
Injury prevention
When lifting, install from top to bottom and remove from bottom to top.
This product can be used normally in the outside temperature range: maximum 40 ℃,
minimum -20 ℃
The composition of the power box during installation will result in an increase in leakage
current. To avoid the risk of electric shock due to high leakage currents, the installation
process must be properly grounded as required.
Important Warning
To prevent electric shock, this product must be grounded
The data cables connected to the system are protected by a special nature
Power supply system Data cable and are not intended for use by the user. If the power cable is broken, only
replace it with a new one, do not try to repair it.
1. Keep the humidity of the environment in which the full-color LED display screen is used, and do not expose to
humidity for a long time.
2. Do not use in harsh natural conditions, such as strong lightning, typhoons, etc.
3. led display main control computer and other related equipment, should be placed in the open, dusty room to
ensure that the computer ventilation and heat dissipation and stable work.
4. Require a stable power supply and good grounding protection, please do not use in harsh environments.
5. It is strictly forbidden to enter water, iron powder and other easily conductive metal objects inside the screen.
LED display big screen is placed in low dust environment as much as possible, large dust will have an impact on
the display effect, while too much dust will cause damage to the circuit. If for various reasons into the water,
please immediately power off and contact maintenance personnel, until the screen body display board dry before
use.
6. LED display switch order: open process: first open the control computer so that it can operate normally before
opening the LED display screen. Close process: first close the LED display, and then close the computer.
7. Do not play for a long time in all white, all red, all green, all blue and other full bright screen, so as not to cause
excessive current, power line heating, LED lamp damage, affecting the service life of the display. Do not
disassemble and splice the screen body at will!
8. It is recommended that the LED display screen rest time is greater than 2 hours a day, in the rainy season LED
screen large screen a week at least once a use more. Generally open the screen at least once a month, light up
more than 2 hours.
9. led display big screen surface can be wiped with alcohol, or use a brush, vacuum cleaner for dust removal, can
not be directly wiped with a wet cloth.
10. led display screen need to regularly check whether the normal work, the line has no damage, such as not
working to timely replacement, line damage to timely repair or replacement. led display screen internal wiring,
non-professionals are prohibited from touching, so as not to electrocution, or cause damage to the line; if there is
a problem, ask professionals to overhaul.