Professional Documents
Culture Documents
Development of An Optimized Welding Procedure To Build A Load Spreader Using Individual Beams
Development of An Optimized Welding Procedure To Build A Load Spreader Using Individual Beams
OPTIMIZED WELDING
PROCEDURE TO BUILD A LOAD
SPREADER USING INDIVIDUAL
BEAMS
Milad Bahrami, Msc, P.Eng.
Presented At:
CanWeld Conference 2017
In order to move a fully developed 2,400 ton ship’s superstructure from a transport barge to the
receiving hull of the iAOR project, currently ongoing at Chantier Davie Canadas Inc., a unique Load
Spreader Beam, capable of supporting the weight of the superstructure, had to be designed and
fabricated. It was critical that this beam be built with minimal induced distortions to allow for a
smooth transition between barge and receiving platform.
The Load Spreader was fabricated using fourteen individual steel beams in three separate sections
with each beam being 25 metres in length with an average thickness between 19 mm to 25 mm.
Fabrication was done using the “Submerge Arc Welding” process allowing the Spreader to be
fabricated with minimal induced distortion.
Due to the individual beam lengths involved it was difficult to fabricate the Load Spreader without
inducing distortions at the welded joints. To compensate for this, a special welding procedure was
developed to limit any