Professional Documents
Culture Documents
Esr 2 K 1
Esr 2 K 1
100 (3.94)
INSTALLATION
41 (1.61) Power consumption
CONFI
•DC: Approx. 2 W
G B RAT
E
110
RUN
Operating temperature: -5 to +60°C (23 to 140°F)
1
(4.33)
ERR.1 ERR
.2
COMMUNICATION
Baud rate: 300, 600, 1200, 2400, 4800, 9600, 14.4 k,
19.2 k, 28.8 k, 38.4 k, 57.6 k, 76.8 k (bps)
Data bit: 7 or 8 bits
Parity: Odd, even or none
Stop bit: 1 or 2 bits
Communication: Half-duplex, asynchronous, no procedure
Data delay time: 300 microseconds
T4 T3 T2 T1
CONFIG B RATE
+ –
RUN ERR.1 ERR.2
ON
1 2 3 4 5 6 7 8
RS-232-C
■ RS-232-C INTERFACE
1 5
6 9
46 (1.81)
105 (4.13)
104 (4.09)
DIN RAIL
35 mm wide
13 (0.51)
92 (3.62) 3 (.12)
40 (1.57) [6 (.24)]
FOR WALL MOUNT.
LEDs DIP SW
Shielded Twisted-pair Cable Isolation
+ T1
D-SUB CONNECTOR
To Other RS-485
Controller RS-232-C
RS-485 Devices – T2 Driver RS-232-C
T3
Jumper* Term. Resist.
T4
+ BAUD RATE
DC POWER SG2 ROTARY SW SG
–
AC Adaptor
SG
*When the device is located at the end of a transmission line via RS-485,
close across the terminal T2 –T3 with the attached jumper pin (or with a leadwire).
Note: RS-485 and power terminals are not isolated from each other.
Use of M-System’s lightning surge protectors is recommended for protecting the
device from induced surges.