Professional Documents
Culture Documents
Samsung Battery
Samsung Battery
Customer(客户):
TABLE OF CONTENTS 目录
New release
1.0 2019-04-03 /
新版本
2. SCOPE 使用范围
This specification is applied to Li-ion rechargeable batter pack (3 series 2 parallel) with “SMBUS interface &
SBS 1.0 standard” delivered to SAMSUNG R470 as power supply for notebook PC.
这份规格是使用在:可充电锂电池包(3 串 2 并的结构),包含 SMBUS 通讯接口并支持 SBS 1.0 的标准;
本产品将使用在 SAMSUNG R470 系列笔记型计算机。
Battery Pack Manufacture has a responsibility to guarantee the Quality of Battery Pack, And Guarantee the
Protection of Cell and Pack at abnormal usage of latest Customer.
电池包的制造包含保证电池包的优良质量,并且保证电芯与电池包在终端用户的异常使用的安全。
4. COMPOSITION 组成内容
The battery pack consists of 6-cell at LG 18650 2600mAh combines with gas gauge control circuit and
protect control circuit.
电池包是由 6 颗 LG 18650 2600mAh 电芯加上电量计电路与锂电池保护电路所组成。
* Note 1
Rate discharge: Constant current discharge (0.5C) till end discharge voltage at 25±2℃.
Rate charge: Constant current charge (0.2C5A) till end voltage 12.6Vdc, 12.6V constant voltage and
0.2C5A current limited charge to current reach 200mA at 25±2℃.
* 附注 1
标准放电: 定电流放电(0.5C5A)放电至放电终止电压,在 25±2℃的操作环境下。
标准充电: 先额定电流充电至 12.6Vdc,然后 12.6Vdc 定电压充电在 0.5C5A 的最大充电电流条件下,
充电到充电电流小于 200mA,在 25±2℃的操作环境下。
7. MECHANICAL 机构项目
No rupture, fire, smoke nor Leave 8 hours connecting: 0.5C /13.5V, power supply at 25±2℃
Over charge (Safety leakage after rated charge.
7 test)
没有破裂、着火、冒烟、漏 于标准充电后,以 0.5C / 13.5V 充电 8 小时。在 25±2℃的操
过充电(安全测试)
液 作环境下。
Short between
terminal Leave battery pack shorted between terminal (+&-) for 1 hour
(Safety test) No rupture, fire nor leakage.
8 after rated charge at 25±2℃.
电源端短路测试(安 没有破裂、着火、漏液 短路电源接脚(+&-)一小时,在 25±2℃的操作环境下。
全测试)
Reverse charge
No rupture, fire nor leakage. Reverse charge for 5 min at 25±2℃
9 (Safety test)
无破裂、着火、漏液 在 25±2℃下,反向充电 5 分钟
反向充电
Operation:
正常操作下
0.75 G zero to peak, 5 to 500 Hz, 0.5 octaves/minute, one
cycle, 5 to 500 to 5 Hz per axis in each of three mutually
No rupture, fire, prominent perpendicular axes.
breakage No interference for Non- operation:
Vibration test charge/discharge
10
震动测试 非正常操作下
没有破裂、着火,没有明显 1.5 G zero to peak, 5 to 500 Hz, 0.5 octaves/minute, one
破损,可以正常充/放电。 cycle, 5 to 500 to 5 Hz per axis in each of three mutually
perpendicular axes.
0.025 G squared/Hz, 10 to 500 Hz, nominal 3.5 G RMS level,
one hour per axis, in each of three mutually perpendicular
axes for a total duration of three hours.
No rupture, fire, prominent
Drop 50% charge battery pack from 1m heights to wooden block
breakage No interference for
Drop test for 6 faces 1 corner.
11 charge/discharge
跌落测试 50%容量的电池,从 1m 高的地方自由落下,X、Y、Z 共 6
没有破裂、着火,没有明确
个方向,每个方向跌落 1 次。
破损,可以正常充/放电。
主要物料清单
Bill of Material mostly
1 IC SN8765 1
UPA2700 or FDS6676 or AO4468 or SI4810B or
2 MOSFET(replaceable) TPC8074 or MT6680 or CT8040 or G4406LS or 2
MDS1525URH
3 Thermal Fuse T6D 139℃ 9A 50V 1
Figure 2
Customer specified
由客户指定
11. SHIPMENT 装运
Top side