Professional Documents
Culture Documents
Mz380401ex Lancer PG1
Mz380401ex Lancer PG1
REAR MUDGUARD
MZ380401EX
INSTALLATION AND HANDLING INSTRUCTIONS
Rear mudguard
Attention
Caution Describes precautions that should be observed in order to prevent injury or damage to
the vehicle or its components, which may occur if sufficient care is not taken.
Note Provides additional information that facilitates installation work.
• Failure to follow these instructions not only prevents the product from working properly but may lead to trou-
ble with the vehicle. Be sure to follow all instructions carefully.
• If there is anything unclear about the installation, handling and/or usage of the product, contact your Mitsub-
ishi Motors dealer for clarification.
• Mitsubishi Motors Corporation is not responsible for any defects or difficulties caused by or resulting from the
failure to follow given instructions.
• We recommend you to have the installation performed at an authorized Mitsubishi Motors dealer.
To the dealer:
Be sure that the customer receives this publication.
JI261228
(06B1544)
j TOOLS (Make the following tools ready for use.)
Socket wrench (10 mm) Phillips screwdriver Drill Drill bit (φ 3 mm, φ 9 mm)
j COMPONENTS (Make sure that all of the following components were included in the kit.)
1 Rear mudguard: 2 (right and left, 1 each) 2 Grommet: 4 3 Tapping screw
(6 x 20): 4
4 Clip: 4 5 Template: 1
j PRECAUTIONS
• Perform the work in a well-ventilated space away from flames.
• Be sure to apply the parking brake securely. Remove the ignition key from the key cylinder.
• The drawings in the Installation Procedures depict the installation of the left side parts. Install the right side
parts in the same manner.
-2-
INSTALLATION PROCEDURES
A. DRILLING ON THE REAR BUMPER
1) Cut off the right and left templates from the tem-
5 Template
plate 5 .
Note
Do not confuse the right and left tem-
plates.
Clip
Clip
-3-
6) Drill a φ 3 mm base hole and then a φ 9 mm hole.
Caution
• Before drilling, wrap the drill bit
tightly with vinyl tape to prevent it
from damaging the other parts.
Approx. 10 mm
Check
Caution
Never use organic solvent such as thin-
ner, benzine, gasoline, etc.
2 Grommet
-4-
3) Fit the rear mudguard 1 on the body and install
the two clips 4 at the bottom of the mudguard. The
front side clip should also fasten the splash shield.
1 Rear mudguard
4 Clip
4 Clip
(Front side clip also fastens the splash shield.)
Check
Check
-5-