Professional Documents
Culture Documents
Huawei Y9 2018 - FLA-LX3 - Administration - Firmware Upgrade - Instructions
Huawei Y9 2018 - FLA-LX3 - Administration - Firmware Upgrade - Instructions
Step 1. Precautions.
Step 1.1. Ensure the Smartphone uses Huawei Official Source Version. If it has been
upgraded to a non-official version or customized versions for other
countries, upgrade may fail and unknown issues may be introduced.
Step 1.2. This Firmware Upgrade Instructions applies only to HUAWEI FLA-LX3
Smartphones, being FLA-LX3 8.0.0.158(C605) the base version and FLA-LX3
9.1.0.121(C605E5R1P1T8) the target version. If the upgrade is performed in
other Smartphone models, a power-on failure may occur.
Step 1.3. Before Upgrade, back up data through Huawei HiSuite Application and ensure
the battery level is higher than 30%.
Step 2. Preparing.
<<<The following activities must be performed on PC>>>
Step 2.1. To perform the upgrade, it is needed to use a microSD Card formatted as ExFAT.
Step 2.2. Verify the microSD Card is readable, writable and the available space is greater
than 8 GB. It is recommended to use a microSD card of SanDisk, Kingston, or
Kingmax.
└─ dload
├─ FLA-L23_hw_la
└─ update_sd_FLA-L23_hw_la.zip
├─ update_sd.zip
Step 2.4. Copy the “dload” folder to the microSD Card root directory.
Step 3. Procedure.
<<<The following activities must be performed on Smartphone>>>
Step 3.1. Power off the phone and insert the microSD card.
Step 3.2. Press and hold "Volume Up + Volume Down + Power" buttons simultaneously
during 15 seconds approximately for the phone to automatically enter the upgrade
mode and perform the upgrade.
Step 3.3. The Smartphone displays the upgrade progress from 0% to 100% until "Update
sucess" message appears, then it is automatically restarted.
Step 3.4. After reboot make a basic setting up, connect to the local Wi-Fi Network, go to the
path "Settings System System update" and verify the new Firmware version
installed is FLA-LX3 9.1.0.121(C605E5R1P1T8).