Professional Documents
Culture Documents
ROSADO - MSDS - 8374 - SDS - GB - en - Interflon - Food - Lube - Aerosol
ROSADO - MSDS - 8374 - SDS - GB - en - Interflon - Food - Lube - Aerosol
ROSADO - MSDS - 8374 - SDS - GB - en - Interflon - Food - Lube - Aerosol
Poison centre
United Kingdom UK National Poison Centre UK National Pois- Mon - Fri 12:00 AM
ons Emergency - 11:00 PM
number: +44 870
600 6266
Section Hazard class Category Hazard class and cat- Hazard state-
egory ment
- Hazard statements
H222 Extremely flammable aerosol.
H229 Pressurised container: May burst if heated.
- Precautionary statements
P210 Keep away from heat, hot surfaces, sparks, open flames and other ignition sources. No
smoking.
P211 Do not spray on an open flame or other ignition source.
P251 Do not pierce or burn, even after use.
P410+P412 Protect from sunlight. Do not expose to temperatures exceeding 50 °C/122 °F.
3.1 Substances
Not relevant (mixture)
3.2 Mixtures
Product description Mixture of vegetable and synthetic oils, additives
and Micpol®
Hazardous ingredients
Notes
C(a): Mixture of isomers
GHS-HC: Harmonised classification (the classification of the substance corresponds to the entry in the list according to 1272/2008/EC,
Annex VI)
K(b): The classification as a carcinogen or mutagen is not required. The substance contains less than 0,1 % w/w 1,3-butadiene
(EINECS No 203-450-8). If the substance is not classified as a carcinogen or mutagen, at least the precautionary statements
(P102-) P210-P403 should apply
U: When put on the market gases have to be classified as ‘Gases under pressure’, in one of the groups compressed gas, lique-
fied gas, refrigerated liquefied gas or dissolved gas. The group depends on the physical state in which the gas is packaged
and therefore has to be assigned case by case.
Following inhalation
If breathing is irregular or stopped, immediately seek medical assistance and start first aid actions. Provide fresh air.
Following ingestion
Rinse mouth with water (only if the person is conscious). Do NOT induce vomiting.
4.2 Most important symptoms and effects, both acute and delayed
Symptoms and effects are not known to date.
4.3 Indication of any immediate medical attention and special treatment needed
none
- Packaging compatibilities
Only packagings which are approved (e.g. acc. to ADR) may be used.
Coun- Name of agent CAS No Identi- TWA TWA STEL STEL Ceiling-C Ceiling-C Nota- Source
try fier [ppm] [mg/m³] [ppm] [mg/m³] [ppm] [mg/m³] tion
Notation
Ceiling-C ceiling value is a limit value above which exposure should not occur
STEL short-term exposure limit: a limit value above which exposure should not occur and which is related to a 15-minute peri-
od (unless otherwise specified)
TWA time-weighted average (long-term exposure limit): measured or calculated in relation to a reference period of 8 hours
time-weighted average (unless otherwise specified)
Skin protection
- Hand protection
Not required.
Respiratory protection
Type: A-P2 (combined filters against particles and organic gases and vapours, colour code: Brown/White).
Partition coefficient
10.1 Reactivity
Concerning incompatibility: see below "Conditions to avoid" and "Incompatible materials". The mixture contains re-
active substance(s). Risk of ignition.
Classification procedure
The method for classification of the mixture is based on ingredients of the mixture (additivity formula).
Skin corrosion/irritation
Shall not be classified as corrosive/irritant to skin.
Carcinogenicity
Shall not be classified as carcinogenic.
Reproductive toxicity
Shall not be classified as a reproductive toxicant.
Aspiration hazard
Shall not be classified as presenting an aspiration hazard.
Other information
Repeated exposure may cause skin dryness or cracking.
12.1 Toxicity
Shall not be classified as hazardous to the aquatic environment.
Remarks
Please consider the relevant national or regional provisions. Waste shall be separated into the categories that can be
handled separately by the local or national waste management facilities.
IMDG-Code AEROSOLS
ICAO-TI Aerosols, flammable
14.3 Transport hazard class(es)
ADR/RID 2 (2.1)
IMDG-Code 2.1
ICAO-TI 2.1
14.4 Packing group not assigned
14.5 Environmental hazards non-environmentally hazardous acc. to the dan-
gerous goods regulations
14.6 Special precautions for user
Provisions for dangerous goods (ADR) should be complied within the premises.
Special provisions (SP) 63, 190, 277, 327, 344, 381, 959
Excepted quantities (EQ) E0
Limited quantities (LQ) 1L
EmS F-D, S-U
Stowage category -
International Civil Aviation Organization (ICAO-IATA/DGR) - Additional information
Danger label(s) 2.1
15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture
Relevant provisions of the European Union (EU)
Seveso Directive
No Dangerous substance/hazard categories Qualifying quantity (tonnes) for the applica- Notes
tion of lower and upper-tier requirements
P3a flammable aerosols (containing Flam. Gas or Flam. Liq.) 150 500 46)
Notation
46) ‘flammable’ aerosols category 1 or 2, containing flammable gases category 1 or 2 or flammable liquids category 1
Note: qualifying quantity = net
Directive on the restriction of the use of certain hazardous substances in electrical and
electronic equipment (RoHS)
none of the ingredients are listed
National inventories
Legend
DSL Domestic Substances List (DSL)
REACH Reg. REACH registered substances
TSCA Toxic Substance Control Act
11.1 Information on hazard classes as defined in Regu- Information on toxicological effects yes
lation (EC) No 1272/2008
14.7 Transport of dangerous goods by road, rail and Agreement concerning the International Carriage yes
inland waterway (ADR/RID/ADN) - Additional in- of Dangerous Goods by Road (ADR) - Additional
formation information
16 Key literature references and sources for data: Key literature references and sources for data: yes
Regulation (EC) No 1272/2008 on classification, la- Agreement concerning the International Carriage
belling and packaging of substances and mix- of Dangerous Goods by Road (ADR). Regulations
tures. Regulation (EC) No. 1907/2006 (REACH), concerning the International Carriage of Danger-
amended by 2020/878/EU.Transport of danger- ous Goods by Rail (RID). International Maritime
ous goods by road, rail and inland waterway Dangerous Goods Code (IMDG). Dangerous
(ADR/RID/ADN). International Maritime Danger- Goods Regulations (DGR) for the air transport
ous Goods Code (IMDG). Dangerous Goods Regu- (IATA).
lations (DGR) for the air transport (IATA).
ADR Accord relatif au transport international des marchandises dangereuses par route (Agreement concern-
ing the International Carriage of Dangerous Goods by Road)
CAS Chemical Abstracts Service (service that maintains the most comprehensive list of chemical substances)
GHS "Globally Harmonized System of Classification and Labelling of Chemicals" developed by the United Na-
tions
IATA/DGR Dangerous Goods Regulations (DGR) for the air transport (IATA)
ICAO-TI Technical instructions for the safe transport of dangerous goods by air
RID Règlement concernant le transport International ferroviaire des marchandises Dangereuses (Regula-
tions concerning the International carriage of Dangerous goods by Rail)
Classification procedure
Physical and chemical properties: The classification is based on tested mixture.
Health hazards, Environmental hazards: The method for classification of the mixture is based on ingredients of the
mixture (additivity formula).
List of relevant phrases (code and full text as stated in section 2 and 3)
Code Text
Disclaimer
This information is based upon the present state of our knowledge. This SDS has been compiled and is solely inten-
ded for this product.