Professional Documents
Culture Documents
Assignment No-2
Assignment No-2
Q6. Find the average value of current when the current that are equidistant are 4A, 5A and 6A.
a) 54
b) GA
c) 15A
d) 10A
Q.7 What is the current found by finding the current in an equidistant region and dividing by n?
a) RMS current
b) Average current
c) Instantaneous current
d) Total current
Q9. What is the type of current obtained by finding the square of the currents and then finding their average and
then fining the square root?
a) RMS current
b) Average current
c) Instantaneous current
d) Total current
Q10._______current is found by dividing the area enclosed by the half cycle by the length of the base of the
half
a) RMS current
b) Average current
c) Instantaneous current
d) Total current
a) RMS current
b) Average current
c) Instantaneous current
d) Total current
a) Greater than
b) Less than
c) Equal to
d) d. Not related
a. Peak factor
b. Crest factor
Q14. Calculate the crest factor if the peak value of current is 10A and the rms value is 2A.
a. 5
b. 10
c. 5A
d. 10A
Q15. What is step down Transformer?
a) Transformer is a device used to convert low alternating voltage to a high alternating voltage
b) Transformer is a device used to convert alternating current to direct current
c) Transformer is a device used to convert low alternating current to a high alternating current
d) Transformers are used only for low alternating voltage
Q25. For a transformer with primary turns 400, secondary turns 100, if 20A current is flowing through primary, we
will get ___________
a) 800A at secondary
b) 40A at secondary
c) 80A at secondary
d) 5A at secondary
Q28. What will happen if the back emf of a DC motor vanishes suddenly?
a) The motor will stop
b) The motor will continue to run
c) The armature may burn
d) The motor will run noisy
Q30. Which part will surely tell that given motor is DC motor and not an AC type?
a) Winding
b) Shaft
c) Commutator
d) Stator
Q32. The current drawn by the armature of DC motor is directly proportional to ________________
a) Torque
b) Speed
c) The voltage across the terminals
d) Cannot be determined
Q34. Which of the following quantity will decrease if supply voltage is increased?
a) Starting torque
b) Operating speed
c) Full-load current
d) Cannot be determined