Professional Documents
Culture Documents
Jaeger-LeCoultre User Manual Q1728410 - 148.8.37 en
Jaeger-LeCoultre User Manual Q1728410 - 148.8.37 en
Jaeger-LeCoultre User Manual Q1728410 - 148.8.37 en
8 1 1 Date
2 2 Crown A
3 Compression key
4 Crown B
3 5 Minute hand
7
6 Seconds hand
4 7 Rotating bezel ring
8 Hour hand
6 5
Despite all the care that the Jaeger-LeCoultre master- It is also essential to have the water resistance of your watch
watchmakers have lavished on making and assembling your regularly checked by an authorised Jaeger-LeCoultre retailer
watch, its accuracy is subject to the influence of gravity, at least once every 2 years, and definitely before any period
magnetic fields, shocks, as well as ageing of the oils. This in which it will undergo prolonged and / or regular immersion.
accuracy is measured by its rate regularity in various positions.
The nature of your temperament and of your daily activities
may cause slight variations in timekeeping. If you were to
notice that your watch is running slow or fast, we advise you
to take it to an approved Jaeger-LeCoultre retailer, who will
make any necessary adjustments.
Wing-nuts
Use
Crown A
1 2 3 Turn the compression key to the «open» position in the
direction of the arrow.
Then pull crown A out to position 2.
The rotating bezel is actuated by turning the crown in either
direction.
Time setting When adjustment is completed, push crown A back to
position 1 and turn the compression key to the «closed»
Crown B
position in the direction of the arrows.The device is thus
Turn the compression key to the «open» position in the secured against accidental handling.
direction of the arrow.
Then pull crown B out to position 3.
The movement is thus locked («stop seconds» function). To
enable precise time setting in seconds, stop the seconds hand
at 12 o’clock.
Move the hands to the desired time, by going past 12 o’clock.
If the date changes with the transition, it is midnight; if not,
it is midday. On the hour signal, push the crown back in to
position 1.The watch starts running again.
When the operation is completed, turn the compression key
to the «closed» position in the direction of the arrows.