Professional Documents
Culture Documents
Plate 5 Instructions
Plate 5 Instructions
Plate 5 Instructions
2. Make another line having an angle of 60 degrees and will pass through the center of the
circle.
3. Measure 2 cm in each line which will start at the circumference of the circle.
4. Draw the first small circle at the center of the bigger circle having a diameter of 4cm (radius
of 2 cm).
5. Draw the remaining circles, use the measured 2cm as the center of the smaller circles.
6. Erase the guide lines.
Figure 2:
1. Draw a circle with a diameter of 12 cm (radius of 6cm), then divide the circle by a horizontal line
passing the center of the circle.
2. Measure 1.5cm, 3cm and 4.5cm from both ends of the line.
3. Draw the arcs using the measured distance as the center pivot of the compass.
4. The do the same in the other side.