Professional Documents
Culture Documents
Dcin GHS Degreaser DM-1130N SDS (En) 2023
Dcin GHS Degreaser DM-1130N SDS (En) 2023
DEGREASER DM-1130N
VersionÿV1.0.0.1
Creation Dateÿ2018/10/08
Revision Dateÿ2023/01/04
Synonyms -
CAS No. -
EC No. -
Molecular Formula -
| Relevant identified uses of the substance or mixture and uses advised against
Relevant identified uses Please consult manufacturer.
2 Hazards identification
| Hazard classification according to GHS
Acute Toxicity – Oral Category 4
Serious Eye
Category 1
Damage/Irritation
| Label elements
Hazard pictograms
1/9
Machine Translated by Google
| Hazard statements
H302 Harmful if swallowed
| Precautionary statements
• Prevention
P264 Wash ... thoroughly after handling.
P270 Do not eat, drink or smoke when using this product.
P280 Wear protective gloves/protective clothing/eye protection/face protection.
• Response
P310 Immediately call a POISON CENTER/doctor.
P330 Rinse mouth.
P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present
and easy to do. Continue rinsing.
• Storage
Storage Not applicable
• Disposal
P501 Dispose of contents/container in accordance with local/regional/national/ international
regulations.
| Hazard description
• Physical and chemical hazards
No information available
• Health hazards
Inhaled Inhalation of the product may produce adverse health effects or irritation of the respiratory tract
following discomfort.
Ingestion Accidental ingestion of the product may be harmful.
Skin Contact Entry into the blood-stream, through, for example, cuts, abrasions or lesions, may produce
systemic injury with harmful effects.
The product can produce severe chemical burns to the eye following direct
Eye contact.
• Environmental hazards
Please refer to 12th chapter of SDS.
3 Composition/information on ingredients
2/9
Machine Translated by Google
General advice Immediate medical attention is required. Show this safety data sheet (SDS) to the doctor
in attendance.
Rinse thoroughly with plenty of water for at least 15 minutes and consult a physician
Eye contact
if feel uncomfortable.
Skin contact Take off contaminated clothing and shoes immediately. Wash off with plenty of water for
at least 15 minutes and consult a physician if feel uncomfortable.
Do not induce vomiting. Never give anything by mouth to an unconscious person.
Ingestion
Call a physician or Poison Control Center immediately.
Move victim into fresh air. If breathing is difficult, give oxygen. Do not use
Inhalation mouth to mouth resuscitation if victim ingested or inhaled the substance. If not
breathing, give artificial respiration and consult a physician immediately.
Ensure that medical personnel are aware of the substance involved. Take
Protecting of first-aiders
precautions to protect themselves and prevent spread of contamination.
5 Firefighting measures
| Extinguishing media
Suitable extinguishing
media Use extinguishing media suitable for surrounding area.
Unsuitable extinguishing
media There is no restriction on the type of extinguisher which may be used.
| Environmental precautions
1 Prevent further leakage or spillage if safe to do so.
3/9
Machine Translated by Google
• Monitoring methods EN
1
14042 Workplace atmospheres. Guide for the application and use of procedures for the assessment of
exposure to chemical and biological agents.
2 GBZ/T 160.1~GBZ/T 160.81-2004 Determination of toxic substances in workplace airÿSeries standardÿ.
| Engineering controls
1 Ensure adequate ventilation, especially in confined areas.
2 Ensure that eyewash stations and safety showers are close to the workstation location.
3 Use explosion-proof electrical/ventilating/lighting/equipment.
4 Set up emergency exit and necessary risk-elimination area.
4/9
Machine Translated by Google
General requirement
Eye protection Tightly fitting safety goggles (approved by EN 166(EU) or NIOSH (US).
Wear protective gloveÿs such as butyl rubberÿ,passing the tests according to EN 374(EU),
Hand protection
US F739 or AS/NZS 2161.1 standard.
If exposure limits are exceeded or if irritation or other symptoms are
Respiratory protection experienced, use a full-face respirator with multi-purpose combination (US) or
type AXBEK (EN 14387) respirator cartridges.
Skin and body protection Wear fire/flame resistant/retardant clothing and antistatic boots.
pH 6.0~8.0ÿ1% solutionÿ
Melting point/freezing No information available
point(ÿ)
Initial boiling point and >35
boiling range(ÿ)
Flash point(Closed No information available
cup,ÿ)
Evaporation rate No information available
Flammability No information available
Upper/lower explosive
Upper limitÿNo information availableÿLower limitÿNo information available
limits[%(v/v)]
Vapor pressure No information available
Relative vapour No information available
density(Airÿ1)
Relative
1.1-1.2
density(Water=1)
Solubility(mg/L) Very soluble in water
n-octanol/water No information available
partition coefficient
Auto-ignition No information available
temperature(ÿ)
Decomposition No information available
temperature(ÿ)
Kinematic viscosity No information available
Particle characteristics Not applicable
5/9
Machine Translated by Google
Possibility of hazardous
No information available
reactions
11 Toxicological information
| Acute toxicity
Product LD50(oral) LD50(dermal) LC50(inhalation,4h)
No information No information
DEGREASER DM-1130N 8180mg/kg (Rat) available available
|Carcinogenicity
| Others
DEGREASER DM-1130N
12 Ecological information
| Acute aquatic toxicity
Product Fish Crustaceans Algae
| Bioaccumulative potential
Bioaccumulative
No information available
potential
| Mobility in soil
Mobility in soil No information available
13 Disposal considerations
| Disposal considerations
Waste chemicals Before disposal should refer to the relevant national and local laws and regulation.
Recommend the use of incineration disposal.
Contaminated Containers may still present chemical hazard when empty. Keep away from hot and ignition
packaging source of fire. Return to supplier for recycling if possible.
Disposal Refer to section 13.1and 13.2.
recommendations
| IMDG-CODE
IMDG-CODE NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS
, ICAO/IATA-DGR
ICAO/IATA-DGR NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS
| UN-ADR
UN-ADR NOT REGULATED FOR TRANSPORT OF DANGEROUS GOODS
15 Regulatory information
| International chemical inve ntory
Component EINECS TSCA DSL IECSC NZIoC PICCS KECI AICS ENCS
7/9
Machine Translated by Google
Note
“ÿ” Indicates that the substance included in the regulations “×” That no data or
included in the regulations
16 Others
| Information on revision
Creation Date 2018/10/08
Revision Date 2023/01/04
Reason for revision -
| Reference
DNEL - Derived No Effect Level IARC - International Agency for Research on Cancer
Transportation Association
NFPA-National Fire Protection Association OECD-Organization for Economic Co-operation and Development
| Disclaimer
This Safety Data Sheet (SDS) was prepared according to UN GHS (the 8th revised edition). The data included
was derived from international authoritative database and provided by the enterprise. Other information was
based on the present state of our knowledge. We try to ensure the correctness of all information. However,
due to the diversity of information sources and the limitations of our knowledge, this document is only for
8/9
Machine Translated by Google
user’s reference. Users should make their independent judgment of suitability of this information for their
particular purposes. We do not assume responsibility for loss, damage or expense arising out of or in any
way connected with the handling, storage, use or disposal of the product.
9/9