Professional Documents
Culture Documents
Fuel Oil System
Fuel Oil System
Fuel Oil System
.1 Essential Components:
· Fuel Pump
· Fuel Injector
.2 Fuel pump:
· Deliver a specific amount of fuel into cylinder through fuel delivery pipe and injector. The start
and stop of fuel injection (with respect to crank angle), is determined at fuel pump.
· Consist of housing, a plunger & barrel, a plunger return spring, a geared control sleeve and a
control rack.
1
· The delivery valve assembly is mounted on top of housing. High pressure fuel discharged pipe is
connected on delivery assembly.
.4 Pumping principle:
· Fuel enters pump through inlet connection and fills fuel chamber surrounding the barrel.
· When plunger is at bottom of stroke, fuel flows through barrel ports (fills space above plunger,
vertical slot cut in plunger and cut-away area below plunger helix)
· As plunger goes up, barrel ports are covered and compression begins.
· Fuel is discharged through lifted delivery valve into high pressure pipe.
.6 Construction:
· Consist of a valve body (which contains the spring and its compression nut). Mating surfaces
between body and nozzle are ground and lapped to give a tight seal.
· Upper chamber in nozzle is charged with fuel and sealed by needle valve when closed. Lower
chamber is sealed by the seat of needle valve and has many atomizing hole (atomize and distribute
fuel spray into combustion chamber).
· A specific fuel pressure lifts the needle valve and oil flows to lower chamber. Additional area of
needle mitre subjected to pressure and causes needle to lift rapidly (allow oil to pass through
atomizer holes into combustion chamber at high pressures).
· Valves will close under spring compression once fuel pump cuts off pressure.