This Arduino code uses a servo motor and ultrasonic sensor to create a basic radar system. The servo motor is attached to pin 12 and sweeps from 15 to 165 degrees, pausing at each interval to take an ultrasonic distance reading using pins 10 and 11. The distance measurements are printed to the serial monitor along with the corresponding servo position.
This Arduino code uses a servo motor and ultrasonic sensor to create a basic radar system. The servo motor is attached to pin 12 and sweeps from 15 to 165 degrees, pausing at each interval to take an ultrasonic distance reading using pins 10 and 11. The distance measurements are printed to the serial monitor along with the corresponding servo position.
This Arduino code uses a servo motor and ultrasonic sensor to create a basic radar system. The servo motor is attached to pin 12 and sweeps from 15 to 165 degrees, pausing at each interval to take an ultrasonic distance reading using pins 10 and 11. The distance measurements are printed to the serial monitor along with the corresponding servo position.
This Arduino code uses a servo motor and ultrasonic sensor to create a basic radar system. The servo motor is attached to pin 12 and sweeps from 15 to 165 degrees, pausing at each interval to take an ultrasonic distance reading using pins 10 and 11. The distance measurements are printed to the serial monitor along with the corresponding servo position.