This document contains an assignment sheet with 4 problems related to friction analysis in machines:
1. Determine the force needed to pull a post out from under a beam supported by the post, given load and friction coefficient information.
2. Calculate the force exerted on pieces of wood held together by a clamp and the torque required to loosen the clamp, given thread friction coefficient and applied torque.
3. Determine the torque and contact angle needed to rotate a pulley on a shaft, given pulley mass, dimensions, and kinetic friction coefficient.
4. Derive an expression for the horizontal force required to roll a loaded cylinder forward, given rolling resistance coefficients and load information.
This document contains an assignment sheet with 4 problems related to friction analysis in machines:
1. Determine the force needed to pull a post out from under a beam supported by the post, given load and friction coefficient information.
2. Calculate the force exerted on pieces of wood held together by a clamp and the torque required to loosen the clamp, given thread friction coefficient and applied torque.
3. Determine the torque and contact angle needed to rotate a pulley on a shaft, given pulley mass, dimensions, and kinetic friction coefficient.
4. Derive an expression for the horizontal force required to roll a loaded cylinder forward, given rolling resistance coefficients and load information.
This document contains an assignment sheet with 4 problems related to friction analysis in machines:
1. Determine the force needed to pull a post out from under a beam supported by the post, given load and friction coefficient information.
2. Calculate the force exerted on pieces of wood held together by a clamp and the torque required to loosen the clamp, given thread friction coefficient and applied torque.
3. Determine the torque and contact angle needed to rotate a pulley on a shaft, given pulley mass, dimensions, and kinetic friction coefficient.
4. Derive an expression for the horizontal force required to roll a loaded cylinder forward, given rolling resistance coefficients and load information.
2022/2023 Students 30th October -3rd November 2022
Assignment Sheet #3: Friction Analysis in Machines
1. Beam AB is subjected to a uniform load of 200 N/m and is supported at B by post BC. If the coefficients of static friction at B and C are 𝝁𝐁 = 0.2 and 𝝁𝐂 = 0.5, determine the force P needed to pull the post out from under the beam. Neglect the weight of the members and the thickness of the beam.
2. A clamp is used to hold two pieces of wood together as shown. The
clamp has a double square thread with a mean diameter of 10 mm and a pitch of 2 mm. The coefficient of friction between threads is μs = 0.30. If a maximum couple of 40 N·m is applied in tightening the clamp, determine (a) the force exerted on the pieces of wood, (b) the couple required to loosen the clamp.
3. A pulley having a diameter of 80 mm and mass of 1.25 kg is supported loosely
on a shaft having a diameter of 20 mm. Determine the torque M that must be applied to the pulley to cause it to rotate with constant motion. The coefficient of kinetic friction between the shaft and pulley is µk=0.4. Also calculate the angle θ which the normal force at the point of contact makes with the horizontal. The shaft itself cannot rotate.
4. The cylinder is subjected to a load that has a weight W. If the
coefficients of rolling resistance for the cylinder’s top and bottom surfaces are aA and aB, respectively, show that a horizontal force having a magnitude of is required to move the load and thereby roll the cylinder forward. Neglect the weight of the cylinder.