Professional Documents
Culture Documents
Cetiol® Ultimate - SDS - Europe - en 191008
Cetiol® Ultimate - SDS - Europe - en 191008
Cetiol® Ultimate - SDS - Europe - en 191008
Page: 1/14
BASF Safety data sheet according to Regulation (EC) No. 1907/2006 as amended from time to time.
Date / Revised: 07.10.2019 Version: 3.2
Date previous version: 28.11.2017 Previous version: 3.1
Product: Cetiol® Ultimate
(ID no. 30597825/SDS_GEN_EU/EN)
Date of print 08.10.2019
Cetiol® Ultimate
1.2. Relevant identified uses of the substance or mixture and uses advised against
Company:
BASF SE
67056 Ludwigshafen
GERMANY
Operating Division Care Chemicals
For the classification of the mixture the following methods have been applied: extrapolation on the
concentration levels of the hazardous substances, on basis of test results and after evaluation of
experts. The methodologies used are mentioned at the respective test results.
Page: 2/14
BASF Safety data sheet according to Regulation (EC) No. 1907/2006 as amended from time to time.
Date / Revised: 07.10.2019 Version: 3.2
Date previous version: 28.11.2017 Previous version: 3.1
Product: Cetiol® Ultimate
(ID no. 30597825/SDS_GEN_EU/EN)
Date of print 08.10.2019
Asp. Tox. 1
H304
For the classifications not written out in full in this section the full text can be found in section 16.
Pictogram:
Signal Word:
Danger
Hazard Statement:
H304 May be fatal if swallowed and enters airways.
No specific dangers known, if the regulations/notes for storage and handling are considered.
Page: 3/14
BASF Safety data sheet according to Regulation (EC) No. 1907/2006 as amended from time to time.
Date / Revised: 07.10.2019 Version: 3.2
Date previous version: 28.11.2017 Previous version: 3.1
Product: Cetiol® Ultimate
(ID no. 30597825/SDS_GEN_EU/EN)
Date of print 08.10.2019
Not applicable
3.2. Mixtures
Chemical nature
For the classifications not written out in full in this section, including the hazard classes and the
hazard statements, the full text is listed in section 16.
On skin contact:
Wash affected areas thoroughly with soap and water.
On ingestion:
Immediately rinse mouth and then drink 200 - 300 ml water, do not induce vomiting, seek medical
attention. If swallowed, seek medical advice immediately and show this container or label.
4.2. Most important symptoms and effects, both acute and delayed
Symptoms: Additional information on symptoms and effects may be included in the GHS labeling
phrases available in Section 2 and in the Toxicological assessments available in Section 11.,
(Further) symptoms and / or effects are not known so far
Page: 4/14
BASF Safety data sheet according to Regulation (EC) No. 1907/2006 as amended from time to time.
Date / Revised: 07.10.2019 Version: 3.2
Date previous version: 28.11.2017 Previous version: 3.1
Product: Cetiol® Ultimate
(ID no. 30597825/SDS_GEN_EU/EN)
Date of print 08.10.2019
4.3. Indication of any immediate medical attention and special treatment needed
Treatment: Treat according to symptoms (decontamination, vital functions), no known specific
antidote.
Storage stability:
Storage temperature: <= 30 °C
629-50-5: Tridecane
1120-21-4: Undecane
PNEC
Data refer to the lead substance
DNEL
No DNELs have been derived.
Hand protection:
Suitable are protective gloves with the following specification. The recommendation is valid for
laboratory conditions, specific workplace conditions must be taken into consideration separately.
Suitable materials also with prolonged, direct contact (Recommended: Protective index 6,
corresponding > 480 minutes of permeation time according to EN 374):
nitrile rubber (NBR) - 0.4 mm coating thickness
Eye protection:
Safety glasses
Body protection:
Body protection must be chosen depending on activity and possible exposure, e.g. apron, protecting
boots, chemical-protection suit (according to EN 14605 in case of splashes or EN ISO 13982 in case
of dust).
Form: liquid
Colour: colourless
Odour: almost odourless
Odour threshold:
not applicable
pH value:
not applicable
Flash point: approx. 74 °C (DIN EN 22719; ISO 2719)
Evaporation rate:
Value can be approximated from
Henry's Law Constant or vapor
pressure.
Flammability: not flammable
Flammability of Aerosol Products:
not applicable, the product does not
form flammable aerosoles
Lower explosion limit:
For liquids not relevant for
classification and labelling.
Upper explosion limit:
For liquids not relevant for
classification and labelling.
Ignition temperature: > 195 °C
Vapour pressure: < 0.5 hPa
(25 °C)
Literature data.
Density: 0.75 g/cm3 (ISO 2811-3)
(20 °C)
Relative vapour density (air):
not applicable
Solubility in water: insoluble
Solubility (qualitative) solvent(s): distilled water
insoluble
Partitioning coefficient n-octanol/water (log Kow):
not determined
Self ignition: not applicable
Other Information:
If necessary, information on other physical and chemical parameters is indicated in this section., No
further information available.
Substances to avoid:
No substances known that should be avoided.
Acute toxicity
Experimental/calculated data:
LD50 (oral): > 2,000 mg/kg
Irritation
Respiratory/Skin sensitization
Assessment of sensitization:
No sensitizing effect.
Experimental/calculated data:
Patch-Test human: Non-sensitizing. (Human patch test)
Assessment of mutagenicity:
The chemical structure does not suggest a specific alert for such an effect.
Carcinogenicity
Assessment of carcinogenicity:
The chemical structure does not suggest a specific alert for such an effect.
Reproductive toxicity
Developmental toxicity
Assessment of teratogenicity:
No data was available concerning toxicity to development.
Repeated dose toxicity and Specific target organ toxicity (repeated exposure)
Aspiration hazard
The product has not been tested. The statements on toxicology have been derived from the
properties of the individual components.
Toxicity to fish:
LC50 > 100 mg/l
According to Annex XIII of Regulation (EC) No.1907/2006 concerning the Registration, Evaluation,
Authorisation and Restriction of Chemicals (REACH): The product does not contain a substance
fulfilling the PBT (persistent/bioaccumulative/toxic) criteria or the vPvB (very persistent/very
bioaccumulative) criteria. Self classification
The product does not contain substances that are listed in Regulation (EC) 1005/2009 on
substances that deplete the ozone layer.
Land transport
ADR
Not classified as a dangerous good under transport regulations
UN number: Not applicable
UN proper shipping name: Not applicable
Transport hazard class(es): Not applicable
Packing group: Not applicable
Environmental hazards: Not applicable
Special precautions for None known
user
RID
Not classified as a dangerous good under transport regulations
UN number: Not applicable
UN proper shipping name: Not applicable
Transport hazard class(es): Not applicable
Packing group: Not applicable
Environmental hazards: Not applicable
Special precautions for None known
user
Sea transport
IMDG
Not classified as a dangerous good under transport regulations
UN number: Not applicable
UN proper shipping name: Not applicable
Transport hazard class(es): Not applicable
Packing group: Not applicable
Environmental hazards: Not applicable
Special precautions for None known
user
Air transport
IATA/ICAO
Not classified as a dangerous good under transport regulations
UN number: Not applicable
UN proper shipping name: Not applicable
Transport hazard class(es): Not applicable
Packing group: Not applicable
Environmental hazards: Not applicable
Special precautions for None known
user
14.1. UN number
See corresponding entries for “UN number” for the respective regulations in the tables above.
14.7. Transport in bulk according to Annex II of MARPOL and the IBC Code
Regulation: Not evaluated
Shipment approved: Not evaluated
Pollution name: Not evaluated
Pollution category: Not evaluated
Ship Type: Not evaluated
If other regulatory information applies that is not already provided elsewhere in this safety data
sheet, then it is described in this subsection.
Advice on product handling can be found in sections 7 and 8 of this safety data sheet.
Information on intended use: This product is of industrial quality and unless otherwise specified or
agreed intended exclusively for industrial use. This includes the mentioned and recommended
usage. Any other intended applications should be discussed with the manufacturer. In particular this
concerns the application for products that are the object of special standards and regulations.
Full text of the classifications, including the hazard classes and the hazard statements, if mentioned
in section 2 or 3:
Asp. Tox. Aspiration hazard
H304 May be fatal if swallowed and enters airways.
Abbreviations
ADR = The European Agreement concerning the International Carriage of Dangerous Goods by Road.
ADN = The European Agreement concerning the International Carriage of Dangerous Goods by Inland
waterways. ATE = Acute Toxicity Estimates. CAO = Cargo Aircraft Only. CAS = Chemical Abstract
Service. CLP = Classification, Labelling and Packaging of substances and mixtures. DIN = German
Page: 14/14
BASF Safety data sheet according to Regulation (EC) No. 1907/2006 as amended from time to time.
Date / Revised: 07.10.2019 Version: 3.2
Date previous version: 28.11.2017 Previous version: 3.1
Product: Cetiol® Ultimate
(ID no. 30597825/SDS_GEN_EU/EN)
Date of print 08.10.2019
national organization for standardization. DNEL = Derived No Effect Level. EC50 = Effective
concentration median for 50% of the population. EC = European Community. EN = European Standards.
IARC = International Agency for Research on Cancer. IATA = International Air Transport Association.
IBC-Code = Intermediate Bulk Container code. IMDG = International Maritime Dangerous Goods Code.
ISO = International Organization for Standardization. STEL = Short-Term Exposure Limit. LC50 = Lethal
concentration median for 50% of the population. LD50 = Lethal dose median for 50% of the population.
TLV = Threshold Limit Value. MARPOL = The International Convention for the Prevention of Pollution
from Ships. NEN = Dutch Norm. NOEC = No Observed Effect Concentration. OEL = Occupational
Exposure Limit. OECD = Organization for Economic Cooperation and Development. PBT = Persistent,
Bioaccumulative and Toxic. PNEC = Predicted No Effect Level. PPM = Parts per million. RID = The
European Agreement concerning the International Carriage of Dangerous Goods by Rail. TWA = Time
Weight Average. UN-number = UN number at transport. vPvB = very Persistent and very
Bioaccumulative.
The data contained in this safety data sheet are based on our current knowledge and experience and
describe the product only with regard to safety requirements. This safety data sheet is neither a
Certificate of Analysis (CoA) nor technical data sheet and shall not be mistaken for a specification
agreement. Identified uses in this safety data sheet do neither represent an agreement on the
corresponding contractual quality of the substance/mixture nor a contractually designated use. It is the
responsibility of the recipient of the product to ensure any proprietary rights and existing laws and
legislation are observed.
Vertical lines in the left hand margin indicate an amendment from the previous version.