Professional Documents
Culture Documents
SA-005 Pump of SA30 - CNC & Servo Software - Documents
SA-005 Pump of SA30 - CNC & Servo Software - Documents
Nov. 2007
Topic:
1. Concerned machines:
Introduced from: For SA30 machine, the new pump is introduced from the machine number
002-002.
3. Retrofit policy:
For the SA30 machine with old pump (P/N:
322012145), if the old pump needs to be
replaced with a new pump, due to the
different size of pump, please apply the
plate (P/N: 334015475) with the new pump
(P/N: 322015473) together. Plate: 334015475
1. Concerned machines:
Introduced from: For SA30 machine, the new handle is introduced from the machine number
002-002.
3. Retrofit policy:
3. Retrofit policy:
1. Concerned machines:
Introduced from: For SA20 machine, the new distributor is introduced from the machine
number 008-003, For SA30 machine, the new distributor is introduced from the machine
number 002-001.
Distributors
3. Retrofit policy:
For the upgrade of software, please refer to the service manual (Chapter 7).
3. Retrofit policy:
1. Concerned machines: For SA20 machine, the new software is introduced from the machine
number 008-010, for SA30 machine, the new software is introduced from the machine
number 002-004.
Note: The CNC software 05.01.01 must be used with the servo software 02.03.03
together!
SA- 005
Nov. 2007
3. Retrofit policy:
1. Concerned machines: For SA20 machine, the new software is introduced from the machine
number 008-010, for SA30 machine, the new software is introduced from the machine
number 002-004.
Note:
(1) After the servo software is upgraded or the SBC-25 board is changed, please also
upgrade the CNC software to 05.01.00!
(2) About the procedure of upgrading the servo software, please refer to the TMN-SA
002E.
3. Retrofit policy:
3. Retrofit policy: