Professional Documents
Culture Documents
30 Fbme10089
30 Fbme10089
net/publication/289290148
CITATIONS READS
32 21,063
2 authors:
5 PUBLICATIONS 52 CITATIONS
EOS North America
24 PUBLICATIONS 125 CITATIONS
SEE PROFILE
SEE PROFILE
All content following this page was uploaded by Aditya Intwala on 05 January 2016.
Abstract- Vertical Take Off and Landing Vehicles (VTOL) are the ones which can take off and land from the same
place without need of long runway. This paper gives the brief idea about numerous types of VTOLs and their
advantages over traditional aircrafts. They can either be of manned type or unmanned type and can be in various sizes
and scales. The paper gives insight to various types of multicopter and evaluates their configurations.
Keywords- VTOL, Multicopter, Dual Copter, Quadcopter, Tri Copter, Hexa copter, Helicopter, aerodynamic, Vertical,
take off, landing, STOL
I. INTRODUCTION
Vertical takeoff and landing vehicles came into existence due to experiments carried out during the years 1950 – 1970
and almost all came out to be failures. Sometimes it used to have short run before the take off hence they were also called
STOL, Shortrun Take Off and Landing vehicle. The flight control and stability of VTOL/STOL is very difficult and is of
prime area of research presently in this field. This paper focuses on how the VTOL emerged gradually over the years and
depicts the current advancement in the field of aerospace. VTOL has basically three configurations up till current
development in this field, wing type configuration, helicopter type configuration and ducted type configuration. Wing
type has fixed wings with vector thrust engine or moving wings with engine, ducted type has ducted rotor which helps to
provide lift, helicopter type has rotor mounted above it to provide lift. Initially the VTOL developed were of wing type
configuration, primarily for military purposes and were man operated but later their importance was know and more and
more advanced designs of it came into existence. The Hover eye platform from Bertin Technologies was first major step
in direction of unmanned VTOL. The Hover eye platform brought breakthrough in the field of ducted type configuration
of VTOL [1]. Recent trends for unmanned aerial vehicles in the field of aerospace and photography application is well
known. Various helicopter type configurations used for UAV are explained along with their advantages over other
configuration here. The latest ongoing research in this field is hoverbike which is a hybrid machine. It uses ducted rotors
to attain required lift in order achieve its objectives. It can be either manned or unmanned. Its concept emerged from the
Hovercraft which has hybrid capability and used ducted fan to hover and maneuver. Design with single engine has
problems of stability and the design with multi engine has problem of managing multi engines effectively. Engine with
exposed rotors proves to be dangerous and so it should be very well considered. The need of the hour is to design a quite,
low cost, low weight, high power to weight and effective control for VTOL and optimize its performance. Such VTOL
can be used for anti terrorist activity, for complete surveillance purposes.
_________________________________________________________________________________________________
© 2015, IJIRAE- All Rights Reserved Page -186
International Journal of Innovative Research in Advanced Engineering (IJIRAE) ISSN: 2349-2163
Issue 2, Volume 2 (February 2015) www.ijirae.com
FIGURE 7: Tricopter Y3
The most well known configuration is the Quadcopter. Here four motors are placed 90’ to each other forming a ‘+’ or ‘X’
configuration hence two types of quad configuration is possible. There are two pairs of CW and CCW propeller to
balance the effect of turbulence. Recently ‘H’ configuration is used for FPV photography. The ‘X’ configuration is used
for photography and ‘+’ configuration is used for flying. This configuration has good lifting capacity and better stability
due to CW and CCW propeller cancel the effect of turbulence.
_________________________________________________________________________________________________
© 2015, IJIRAE- All Rights Reserved Page -188
International Journal of Innovative Research in Advanced Engineering (IJIRAE) ISSN: 2349-2163
Issue 2, Volume 2 (February 2015) www.ijirae.com
_________________________________________________________________________________________________
© 2015, IJIRAE- All Rights Reserved Page -189
International Journal of Innovative Research in Advanced Engineering (IJIRAE) ISSN: 2349-2163
Issue 2, Volume 2 (February 2015) www.ijirae.com
Similar to tricopter Y6 configuration has 6 motors placed in ‘Y’ configuration. It uses CW and CCW propeller on the
same arm, one motor up and other motor below hence intotal 6 motors. Due to this it have higher lifting capacity
compared to tricopter and can small in size which remover the disadvantage of hexacopter H6.
Similar to Y6, X8 uses four pairs of CW and CCW propellers (in total 8 motors) in the form of ‘X’ configuration to
reduce the size without affecting the lifting capacity of octacopter.
_________________________________________________________________________________________________
© 2015, IJIRAE- All Rights Reserved Page -190
International Journal of Innovative Research in Advanced Engineering (IJIRAE) ISSN: 2349-2163
Issue 2, Volume 2 (February 2015) www.ijirae.com
The above image shows the Hoverbike Conceptual Model Manufactured by Aerofex Company based on the US patent
by Sanders Jr John K et al. (2006) [8].
III. APPLICATIONS
VTOL vehicle can be used for various purpose like military applications, Surveillance application for Defense, Aerial
photography, Payload caring, in Aerospace application, as a mode of transportation, as material delivery system, as AGV
(Automated Guided Vehicle) in industries, for photography purpose, It can be used during natural calamities like flood,
earthquakes etc to know the whereabouts of the victims and to provide them with food packets, for rescue missions, etc.
Amazon is thinking of providing their product delivery through such mini VTOL vehicles recently.
IV. CONCLUSION
Thus we can get the rough idea about the Initial history of VTOL and the recent advancement in this field. It also depicts
various configurations of modern UAV and its pros and cons. Octocopter is more suitable for aerial photography as it is
more stable and more lifting capacity. For small scale application but high lifting capacity than coaxial motor
arrangement can be used as in Y6 and X8 configuration it gives compact design with high payload carrying capacity. For
hobby activity small quadcopter or tricopter configuration can be used.
REFERENCES
[1] Binetti, P.; Trouchet, D.; Pollini, L.; Innocenti, M.; Hamel, T.; Le Bras, F. (2007) “The Flight Control System of the
Hovereye® VTOL UAV” In Platform Innovations and System Integration for Unmanned Air, Land and Sea Vehicles
(AVT-SCI Joint Symposium) (pp. 34-1 –34-16).
[2] "Heads Up Fighters." Popular Mechanics, May 1954, pp. 96–97
[3] P.1127 - Hawker's V/STOL Strike Aircraft a 1960 Flight article
[4] "Yak-36 Forger—interim V/Stol." Flight International, 2 May 1981.
[5] Whittle, Richard. The Dream Machine: The Untold History of the Notorious V-22 Osprey. New York: Simon &
Schuster, 2010. ISBN 1-4165-6295-8.
[6] "Vertical take-off/landing aircraft: Yak-38." Yakovlev Design Bureau, 16 July 2008. http://aerofex.com/theaerox/
[7] John K. Sanders, Jr,J. Kenneth Sanders, Arturo Aviles, Jr., Arturo F. Aviles "quiet vertical takeoff and landing
aircraft using ducted, magnetic induction air-impeller rotors" US 7,032,861 B2 (2006)
_________________________________________________________________________________________________
© 2015, IJIRAE- All Rights Reserved Page -191