Professional Documents
Culture Documents
Multiflo CF-85MV C-7-1 Spec Sheet
Multiflo CF-85MV C-7-1 Spec Sheet
Multiflo CF-85MV C-7-1 Spec Sheet
Features
• Solids handling dewatering pump
• Close coupled pump assembly ensuring
accurate pump alignment
• Auto vacuum pump priming system
• Robust pump unit base construction
with inbuilt baffled fuel cell
• Pump unit base designed for various
mounting options
• Engine canopy
• Lift Points (2)
• Two-pack epoxy paint system
• Comprehensive installation, operations
and spare parts manuals
The Multiflo® CF-85MV unit provides a wide range of standard inclusions and a • Starter motor and battery isolators
comprehensive selection of optional features to suit your dewatering needs. • Low flow protection
DN 200mm
Discharge
DN 150mm
3225 1649
Copyright © 2018, Weir Minerals Australia Ltd. All rights reserved. MULTIFLO and HYDRAU-FLO are trademarks and/or registered
trademarks of Weir Minerals Australia Ltd; LINATEX is a trademark and/or registered trademark of Linatex Limited; WEIR and
Weir Minerals WEIR (logo) are trademarks and/or registered trademarks of Weir Engineering Services Ltd. Certain features of the technology
featured in this publication may be protected by pending and granted patents in the name of The Weir Group PLC and/or one of
NOTE: THIS DRAWING SHALL BE READ IN CONJUNCTION WITH MF262946 - STANDARD DRAWING NOTES PAGE FOR FABRICATION, WELDING,
FINISHING AND INSPECTION REQUIREMENTS.
THIS DRAWING SHALL BE READ IN CONJUNCTION WITH DOCUMENT WMMEDPS-001WEIR MINERALS MULTIFLO ENGINEERING DEPARTMENT
its subsidiaries. ** CATERPILLAR, CUMMINS and KENSHO are not trademarks belonging to any company forming part of The
PROCEDURES AND STANDARDS FOR ALL MACHINING AND ASSEMBLY REQUIREMENTS
multiflo@mail.weir -
-
-
- Weir Group PLC. WMD0759/062018
-
MASS: 3563.9 kg
-
-
-
-
-
-
-
WELD CAT.
FINISH CODE
ASSEMBLY
Copyright © Weir Minerals Australia Ltd. 2018
www.minerals.weir
- - - - - - DO NOT SCALE Weir Minerals Austalia Ltd. ("the Company") is the owner of the copyright and all confidential information in this drawing. SCALE 1:20 U.N.O. 3rd ANGLE PROJEC
The drawing must not be copied in whole or in part, in any form or by any means, and the information in it must not be
- - - - - - IF IN DOUBT - ASK disclosed to any person, or used for any purpose other than the specific purpose for which it has been provided,
without the prior written consent of the Company.
DESIGN J.A 11.07.16 DRAWING
- - - - - - MULTIFLO
®