This document defines various abbreviations and acronyms used in oil and gas drilling operations. It includes terms related to drilling equipment, mud properties, drilling parameters, wellbore operations, and downhole conditions. Some examples are BHA for bottom hole assembly, ECD for equivalent circulating density, MW for mud weight, RIH for run in hole, TOC for top of cement, and WOB for weight on bit. In total it defines over 80 common abbreviations.
This document defines various abbreviations and acronyms used in oil and gas drilling operations. It includes terms related to drilling equipment, mud properties, drilling parameters, wellbore operations, and downhole conditions. Some examples are BHA for bottom hole assembly, ECD for equivalent circulating density, MW for mud weight, RIH for run in hole, TOC for top of cement, and WOB for weight on bit. In total it defines over 80 common abbreviations.
This document defines various abbreviations and acronyms used in oil and gas drilling operations. It includes terms related to drilling equipment, mud properties, drilling parameters, wellbore operations, and downhole conditions. Some examples are BHA for bottom hole assembly, ECD for equivalent circulating density, MW for mud weight, RIH for run in hole, TOC for top of cement, and WOB for weight on bit. In total it defines over 80 common abbreviations.
AV – Annular Velocity LC – Lost Circulation TIH – Trip In Hole LCM – Lost Circulation Material TOC – Top Of Cement BF – Buoyancy Factor Len – Length in feet TOF – Top Of Fish BHA – Bottom Hole Assembly LOT – Leak Off Test TOH or TOOH – Trip Out Of Hole BHP – Bottom Hole Pressure TOL – Top Of Liner BOP – Blow Out Preventor TVD – True Vertical Depth BOPE – Blow Out Preventer Equipment MAASP – Max Allowable Annular Surface Pressure BPUTS – Bring Pumps Up To Spe MASP – Max Anticipated Surface Pressure MD – Measured Depth CC – Circulate and Condition mud MGS – Mud Gas Separator CLF – Choke Line Friction MI – Mud Increment CMW – Current Mud Weight MISICP – Maximum Initial Shut-in Casing Pressure CP – Casing Pressure MOP – Margin of Over Pull MW – Mud Weight in ppg DC – Drill Collar Dh – Diameter of hole in inches NP – Neutral Point WL – Water Loss or Wire Line DP – Drill Pipe WOB – Weight On Bit DPP – Drill Pipe Pressure OBM – Oil Based Mud WOC – Wait On Cement OMW – Original Mud Weight WOO – Wait On Orders ECD – Equivilant Circulating Density WOW – Wait On Weather EOB – End of Build OPT – Optimum ESP – Estimated Stuck Point or Electical Submersible Pump YP – Yield Point PG – Pressure Gradient FD – Fluid Density PI – Pressure Increment FIT – formation integrity test POH – Pull Out Hole FOSV – Full Opening Safety Valve PP – Pore Pressure FP – Formation Pressure PPG – Pounds Per Gallon FrP – Friction Pressure FV – Funnel Viscosity RIH – Run In Hole RPM – Rounds Per Minute GPM – Gallons Per Minute RSS- Rotary Steerible System
HHP – Hydraulic Horse Power SCR – Slow Circulating Rate
HP – Hydrostatic Pressure SG – Specific Gravity SICP – Shut-in Casing Pressure IBOP – Inside Blow Out Preventer SIDPP – Shut-in Drill Pipe Pressure SOBM – Synthetic Oil Based Mud ICP – Initial Circulating Pressure SP – Surface Pressure ISICP – Initial Shut-in Casing Pressure SPM – Strokes Per Minute SPM Valve – Side Pocket Mandrel Valve KLF – Kill Line Friction SPR – Slow Pump Rate KMW – Kill Mud Weight KOP – Kick Off Point