Professional Documents
Culture Documents
Hantek Mode Emploi 2
Hantek Mode Emploi 2
Operating Basics
u Input Connectors
Click the software icon on the desk after you finished the software setting and equipment
connecting. Then a user interface will be showed as follows:
In addition to displaying waveforms, the display area is filled with many details about the
waveform and the oscilloscope control settings.
file:///C:/Users/joe/AppData/Local/Temp/~hhA1E2.htm 07/06/2020
Operating Basics Page 2 of 10
2. The Toolbar
15. The markers show the reference points of the displayed waveforms. If there is no
marker, the channel is not displayed.
file:///C:/Users/joe/AppData/Local/Temp/~hhA1E2.htm 07/06/2020
Operating Basics Page 3 of 10
file:///C:/Users/joe/AppData/Local/Temp/~hhA1E2.htm 07/06/2020
Operating Basics Page 4 of 10
file:///C:/Users/joe/AppData/Local/Temp/~hhA1E2.htm 07/06/2020
Operating Basics Page 5 of 10
file:///C:/Users/joe/AppData/Local/Temp/~hhA1E2.htm 07/06/2020
Operating Basics Page 6 of 10
1. Select channel : User can select the channel by clicking the Combo box.
5. Probe: Set the Select one according to the probe attenuation factor to
ensure correct vertical scale reading
file:///C:/Users/joe/AppData/Local/Temp/~hhA1E2.htm 07/06/2020
Operating Basics Page 7 of 10
Click ¡±Setup¡±->¡°Horizontal¡±
The following figure shows the Horizontal System window. It shows the horizontal
parameters settings.
file:///C:/Users/joe/AppData/Local/Temp/~hhA1E2.htm 07/06/2020
Operating Basics Page 8 of 10
2. Trigger Sweep: Selects the trigger sweep mode to AUTO, NORMAL or SINGLE
file:///C:/Users/joe/AppData/Local/Temp/~hhA1E2.htm 07/06/2020
Operating Basics Page 9 of 10
4. Trigger Slope: Selects the edge trigger slope to Positive or Negative slope
HANTEK1008 only supports Edge trigger and does not support EXT trigger source.
Input Connectors
file:///C:/Users/joe/AppData/Local/Temp/~hhA1E2.htm 07/06/2020
Operating Basics Page 10 of 10
file:///C:/Users/joe/AppData/Local/Temp/~hhA1E2.htm 07/06/2020