Professional Documents
Culture Documents
CHK PH 0001
CHK PH 0001
1TB02011-011C49-FFC-CHK-PH-0001
Document No - 1TB02011-011C49-FFC-CHK-PH-0001
Rev - C0
Page 1 of 2
Document Cover Page Document Ref. 1TB02011-011C49-FFC-CHK-PH-0001
Revision History
Revision Revision - Revision Approved
No. June-Date by by Description of Revision Status
Inspection Checklist for For Review
Rashad Domestic Water
C0 11-09-23 SIHJ Distribution Piping
Arab
(Inside Building)
Distribution
Name Title Department Date Issued
Page 2 of 2
TRIPPLE BAY ROSEWOOD HOTEL PROJECT
Checklist Description: Domestic Water Network Installation & Specialties ITP No: ITP-ME-0001
1. GENERAL
Check piping level with 0.25 percent slope downward toward drain
3.1
and plumb.
Page 1 of 3
TRIPPLE BAY ROSEWOOD HOTEL PROJECT
Checklist Description: Domestic Water Network Installation & Specialties ITP No: ITP-ME-0001
In Concrete Slab, both Hot and Cold water PPR pipes shall be pre-
insulated by the manufacturer, any insulation of the pipes using
3.7
Elastomeric insulation need to be approved by Authority Having
Jurisdiction.
Ensure Pipe & fittings are welded as per approved Method and all
3.8 welded joints are visually free from deformity, burrs, uneven
seams and other similar welding defects.
Fittings for PEX Tube: ASTM F 1807, metal-insert type with copper
4.2 crimp rings and matching PEX tube dimension. Or as per approved
MTS (Q&E type)
Hot & Cold Droppers are spaced atleas 150 mm to aviod Heat
4.9
Transfer
The radius of bending for the pipe and its conduit, when rising from
the floor to the wall, should be [at least) 8 times the outer
4.10 diameter of the conduit pipe (R=B D) to allow free motion of the
inner pipe, inside its conduit, including easy threading and
extraction.
Page 2 of 3
TRIPPLE BAY ROSEWOOD HOTEL PROJECT
Checklist Description: Domestic Water Network Installation & Specialties ITP No: ITP-ME-0001
Conduit piping and water piping between terminal points and the
4.11 distributor should be laid in one whole unit, with no branching or
couplers
5. LEAKAGE TESTING
Ensure the test has been carried out in the presence of the Client
5.1 representative who shall verify the test results as per attached
Test form. (1.5 times working pressure or as per site requirement)
Page 3 of 3
TRIPPLE BAY ROSEWOOD HOTEL PROJECT
Location: Area:
Test Parameters
Required Test pressure: Test Fluid: Water Other
Test Equipment
Type: Range: Calibration date:(From) Calibration date:(TO)
Pressure Gauge 1
Pressure Gauge 2
Pressure Gauge 1:
Pressure Gauge 2 :
Page 1 of 1