Professional Documents
Culture Documents
ST 350-87-1987 Chevrolet GMC Light Truck Wiring Manual Complete 11x17
ST 350-87-1987 Chevrolet GMC Light Truck Wiring Manual Complete 11x17
J 1 T
approval. The right is reserved to make changes at any time without notice.
I
SUBJECT PAGE COLOR oFWIRE INSULATION
WIRE WIRE SiZE BlK •.•.•••••. Black PPl ••••••••• Purple
CIRCUIT IN SQ. MM.
Description • • • 2 Iii 8RN •...••..• Brown TR ••.•.••••••Tracer
III III III • III III III III III III III III III III III III • • • • III • • • • • III III III • • • • III • • • III III III • • III III III, .. III III III • III III III • III III III III III III III III III III III III III • III III III • III III III III III III III III
NUM8ER
Tracing Circuits on the New Diagrams••••••• ~ . • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • . . . • . . . . . . • • •• 2 CHK ....•..•.Check VEL ••••••••. Yellow
* lOCATION
Basic Electric Circuits . • • • . . • • • • • • • • • • • • • . . • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • . • • • • • •• 4 OF CR ••.•.•••.•. Cross II ....•.•.... Parallel
Diagnostic Tools .......................................................".... • • • • . • . . • • • • . • • ". • • •. 9 OTHER GRN •.•••••••Green WHT ••••••••• White
Wire Size Conversion Table •••••••••••••••••••••••.•••••••••••••••••••••••••••••••••••••••••••• 11 END NAT •••••••• Natural 8lU ••••••••••• Blue
On-Vehicle Service ••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••• 12
I Circuit Maintenance and Repair ••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••• 12
Weather Pack Connectors •••••••••••.••••••••••••••••••.••••••••••.••••••••.••••••••••.••..•••• 12
("ADDRESS")
an address for each wire entering the harness to show CRUISE CONTROL GROUND CIRCUITS (Figure 4)
I RV Truck
where it comes out. If the other end of the wire is on a
different page, the page number and address will be
1. The system is grounded at the bus bar ground. The
ground wire is coded 1508 19 0.8 8lK. This
indicates that 1508 is a black wire and the next
shown at the bottom right hand corner of the schematic.
address is 19.
I Figure 1 explains the wire coding. The contents page lists
the harnesses by section number and name. . 2. This is where the ground wire enters the harness.
3. There is a· splice in the harness at 19. This is
indicated by the triangle with the dot in the center. It
I TRACING CIRCUITS has four wire codes, indicating that four wires are
spliced there: 150A. 1508, 150C and 1500.
EXAMPLE: CRUISE CONTROL POWER SOURCE 4. At location M13, wire 150A connects to pin C of the
I WITH THE MANUAL TRANSMISSION (Figure 2)
1. Circuit 139 originates at the fuse block. Refer to
figure 3.
six terminal connector.
5. 150A at location M13 mates to wire 150E, which is
addressed J13.
""",,.;""""P_-" ..........- °1 ~~