om
Cis the correct answer as there is always an acceleration of 9.81 ms
A is not the correct answer as there is always an acceleration of 9.81 m s@
Bis not the correct answer as there is always an acceleration of 9.81 ms
Dis not the correct answer as there is always an acceleration of 9.81 ms
The only correct answer is B as.s = vt and s= 1.2 = 0.9
A is not the correct answer as s = vt and s = 1.2 * 0.9
C is not the correct answer as s = viand s = 1.2 * 0.9
Dis not the correct answer ass = vt and s = 1.2 * 0.9
The only correct answer is C as the acceleration is positive while the fuel is still
buming. It then becomes negative, while still travelling upwards, as the only forces
acting on it are downwards (weight and drag).
Ais not the correct answer because the acceleration should be constant as there is
a constant upwards thrust from the fuel.
Bis not the correct answer because the acceleration should be constant as there ts
a constant upwards thrust from the fuel. The acceleration should become negative
before T.
Dis not the correct answer because the acceleration becomes negative as the fuel
runs out and not at the maximum height.
Cis the correct answer
This is because s=!29/. So if in one unit of time the sphere has fallen
one unit of distance, ie. from image | to image 2, then in 2 units of
time it will have fallen 4 units of distance, ie. from image 1 to R.
Dis the correct answer
A is not the correct answer as the areas under the two graphs are not both zero.
B is not the correct answer as the areas under the two graphs are not equal.
C is not the correct answer as P is at the initial position,
Ais the correct answer
B is not the correct answer as the change in velocity is not 2m s
C is not the correct answer as it gives a negative time, and the collision takes a positive
amount of time.
D is not the correct answer for the same reason that B is not.
Bis the correct answer
Ais not the correct answer as a velocity requires two measurements
C is not the correct answer as a velocity requires two measurements
D is not the correct answer as a velocity reauites two measurements10
Bis the correct answer
Ais not the correct answer as areas above and below time axis not equal
C is not the correct answer as gtaph starts fom zero
Dis uot the correct answer as graph starts from zero
Cis the correct answer
A is not the correct answer as no indication in Q9 of extremely high velocity
required to change displacement apparently instantly
Bis not the correct answer as lines straight, indicating no change in velocity
D is not the correct answer as lines straight, indicating no change in velocity
Cis the correct answer
Ais incorrect because the velocity should be squared
Bis incorrect because the displacement should be doubled and the velocity squared.
Dis incorrect because the displacement should be doubled
Dis the correct answer
Ais incorrect because the acceleration is not positive
Bis incorrect because the acceleration is decreasing
C is incorrect because the acceleration is constant
Bis the correct answer
Ais incorrect because the graph would have a gradient of g/2
Cis incorrect because the graph would have a gradient of 2/g
Dis incorrect because the graph would have a gradient of I/g
Cis the correct answer
A is incomect because the ball bearing is not in the oil at V
Bis incorrect because the ball bearing has not reached terminal velocity at W
Dis incomect because the ball bearing has not reached terminal velocity at W
Cis the correct answer
A is incorrect because the acceleration does not reach zero
B is incorrect because the acceleration does not reach zero
Dis incorrect because the acceleration does not reach zero
Bis the correct answer
Ais incorrect because gradient is velocity, not acceleration
Cis incorrect because gradient is rate of change of
acceleration not velocity
Dis incorrect because gradient is rate of change of acceleration, not
displacementa
an
Ais the correct answer
Bis incorrect because the distance has not been doubled and the
time has not been squared
Cis incorrect because the distance is in the wrong unit
Dis incorrect because the distance is in the wrong unit, has not been
doubled and the time has not been squared
Ais the only correct answer
Bis incorrect because final displacement is measured from 0, not —L
C is incorrect because displacement is not the area between the line and the f axis,
and velocity is 3m ~ 65, not 6m +35
Din incorrect because velocity is 3m~ 6s, not 6m~3s
Ais the only correet answer
Bis incorrect because the velocity is always zero
C is incorrect because the velocity is always positive
Din incorrect because velocity is zero except for a very short time.
Cis the only correct answer
Ais incorrect because the 2 should be above the line, and the 0.63 should be
squared
Bis incorrect because the 2 should be above the line
Dis incomect because he 0.63 should be squared
The correct answer is B
Ais incorrect because air resistance would reduce the acceleration
Cis incorrect because drop time is unaffected by horizontal motion
Dis incorrect because a greater time would give a lower acceleration
‘The correct answer is B because for a constant resultant force acceleration
increases if mass decreases
Ais incorrect because a constant acceleration for a decreasing mass would
requite a decreasing resultant force
C is incorrect because a decreasing acceleration for a decreasing mass would
require a decreasing resultant force
Dis incorrect because a decreasing acceleration for a decteasing mass would
require a decreasing resultant force
The correct answer is D because the area below the f axis represents negative
displacement
Ais incorrect because P is above the line and Q should be subtracted
Bis incorrect because P is above the line
Cis incorrect because Q should be subtracted
Bis the correet answer
Ais incomect because acceleration is rate of change of velocity
Cis incomect because speed is the magnitude of velocity.
Dis incomect because time taken is the x-axis variable
A ls the correct answer
Bis incorrect because the gradient is zero except at one point.
Cis incorrect because the gradient begins negative and becomes positive.
Dis incorrect because the positive and negative gradients are constant except at
one point,‘The correct answer is D
A is not the correct answer because the drop speed would be too slow if the
flow were laminar
Bis not the comect answer because the ball bearing should not be moving at
terminal velocity at all
Cis not the correct answer because to calculate g you must know the initial
velocity and the student isn't measuring that
‘The correct answer is C
Ais not the correct answer because the acceleration is not 5 ms
Bs not the correct answer because the acceleration is not 9.81 ms”
Dis not the correct answer because this expression is not dimensionally
correct and the acceleration is not 9.8] ms"
The correct answer is B
A is not the correct answer because the acceleration is not positive
Cis not the correct answer because the acceleration does not increase
Dis not the correct answer because the acceleration does not decrease