Download as pdf
Download as pdf
You are on page 1of 12
1 Which of the following is a veetor quantity? A. work done O B time 1 C temperature 1 D displacement (Total for Question 1 = 1 mark) 2. Which of the following is equivalent to 1 kilowatt-hour? 0 A 0283 O B o2sw © 36x 105 OD 36x 10W (Total for Question 2 = 1 mark) 1 Quantities in physics are classified as either vectors or scalars Which of the following units could only be used for a scalar quantity?” O Amst OG Bos? OC kem: GD kgm= (Total for Question 1 = 1 mark) 9A student walked 12km on a bearing of 135° and then walked 20km on a bearing of 340° as shown. Wisgram Brscale 20km 340° 12km Which of the following could represent the final displacement of the student from his starting point? ac Op (Total for Question 9 = 1 mark) 1 Which row of the table gives the meaning of the stated unit prefixes? micro centi a 10° 107 a 10° 10° a 10° 107 ao 10* 10° (Total for Question 1 = 1 mark) 2 All quantities may be expressed in terms of SI base units ‘Which of the following are the base units for the moment of a force? OA kgms? OB kem’s? OC kms? OD kems? (Total for Question 2 = 1 mark) 3. A student measured the diameter of a length of wire in order to determine its cross-sectional area. The following measurements were taken at various positions along the wire and at various orientations around the wire, All measurements are in mm. 13601. Which of the following expressions should the student use to determine the cross-sectional area of the wire in mm? GA a(l.see GB x(1s2P Gc x@.78" OD x@.767 (Total for Question 3 = 1 mark) 5. The steps on an escalator move with a speed of 0.5ms“!, The vertical component of their velocity is 0.3ms* upwards 0.3ms* Which of the following is the horizontal component of velocity for the escalator steps? G A 02ms* O B O04ms* @ C 05ms* O D 08ms* (Total for Question § = 1 mark) 39 1 Which of the following quantities has the SI base units kgm? s OA force © B momentum O C power 1D work done (Total for Question 1 = 1 mark) 3. The diagrams below show the velocity of an object before and after a force is applied. The magnitude of the velocity did not change | / before after Which of the following arrows represents the direction of the change in velocity? ag ~~ ~~ Roe A B c D ga os ac op (Total for Question 3 = 1 mark) 1 Which of the following units is only used with vector quantities? Gal Oo Bm OcNn Ovpw (Total for Question 1 = 1 mark) 4 Acar travels north with a velocity of +50ms”. While still travelling north, the car slows to a velocity of +20ms", Which of the following is the change of velocity of the ear? GA +30ms? © B -30ms? @ C +70ms* O D -70ms* (Total for Question 4 = 1 mark) 5 Two forces P and Q act on an object as shown. Q Which of the following is a correctly drawn, scaled, vector diagram for the resultant R of forces P and Q? P B P Q c D oa os a op (Total for Question § = 1 mark) 8 Which of the following is a vector quantity? TA density 1 B Kinetic energy O ¢ momentum OD viscosity (Total for Question 8 = 1 mark) 1 Which of the following is a scalar quantity? GA weight OB momentum GC terminal velocity CD kinetic energy (Total for Question 1 = 1 mark) 10 Two forces F, and F, act on an object, as shown, Which of the following is a correctly drawn scaled vector diagram for the resultant R of the forces F, and F,? (Total for Question 10 = 1 mark) 4 A tennis ball is moving through the air. The diagram shows the horizontal and vertical components of its velocity. Which of the following expressions gives the magnitude of the velocity in ms"? 13.2 sin22.6° B BB 132xsin22.6° 35 Boe Re BD 55x -sin22.6° (Total for Question = 1 mark) 6 Abblock of wood is stationary on a frictionless ramp as shown. ‘The block is held in place by a string. The weight of the block is 17. The foree applied to the block by the string is F, block £ ramp. Ww A triangle of forces can be used to determine the magnitude and direction of the normal contact force NV acting on the block. Which of the following triangles is correct? booao coe (Total for Question 6= 1 mark) 2. Physical quantities may be vectors or scalars. Which row of the table is correct?” Force Mass Acceleration Oa scalar vector scalar Oo Bs scalar scalar vector Be vector vector scalar Oo pb vector scalar vector (Total for Question 2 = 1 mark) The diagram shows a student during a parachute jump on a windy day. The vertical component of her velocity is 5.0ms". The horizontal component of her velocity is 8.0ms". She descends at an angle 6 to the vertical. a sm Which row of the table gives expressions for the magnitude and angle of the student’s resultant velocity? Magnitude / ms* are oa ee tant 8 5 oes fee 8 oe Were tant Op WsF (Total for Question 4 = 1 mark) 10 Which row of the table contains two units that are not equivalent? Unit 2 Oa Ww o Bs kgms? Ns oc Nkg? ms? op Nm J (Total for Question 10 = 1 mark) 3° Which of the following is a scalar quantity? OA force OB momentum © velocity OD work (Total for Question 3 = 1 mark) 2. Which of the following quantities is a vector? G A energy OB mass © C momentum SD power (Total for Question 2 = 1 mark) 7 Two forces, X and Y, act at a point. Which of the following vector diagrams shows the magnitude and direction of the resultant of the two forces? x resultant force resultant force c: Boag ° 1 Which of the following is a scalar quantity? (A displacement 1B moment of a force O C power OD weight resultant force resultant force D (Total for Question 7 = mark) (Total for Question 1 = 1 mark) 6 Assoap bubble is being blown by the wind. The free-body force diagram shows the forces acting on the bubble. P is the force of the wind, I’is the weight of the bubble and Ui the upthrust acting on the bubble. Which of the following vector diagrams shows the resultant force F acting on the bubble? F F Ww-u wu wu Booaoa vow > (Total for Question 6 = 1 mark)

You might also like