Professional Documents
Culture Documents
Cyprus National Annex EN 1993-1-11
Cyprus National Annex EN 1993-1-11
Cyprus National Annex EN 1993-1-11
CYS EN
1993-1-11:2006
Eurocode 3:
Design of steel
structures
Part 1-11:
Design of structures
with tension
components
3UHSDUHGE\
(XURFRGHV&RPPLWWHH6FLHQWLILFDQG7HFKQLFDO
&KDPEHURI&\SUXVXQGHUD0LQLVWU\RI,QWHULRU V3URJUDPPH
NATIONAL ANNEX
TO
CYS EN 1993-1-11: 2006 Eurocode 3: Design of steel
structures
Part 1-11: Design of structures with tension components
This National Annex has been approved by the Board of Governors of the Cyprus
Organisation for Standardisation on 11/06/2010.
National Annex to CYS EN 1993-1-11: 2006 Eurocode 3: Design of steel structures
Part 1-11: Design of structures with tension components
INTRODUCTION
This National Annex has been prepared by the Eurocodes Committee of the Technical
Chamber of Cyprus which was commissioned by the Ministry of Interior of the Republic of
Cyprus.
NA 1 SCOPE
This National Annex is to be used together with CYS EN 1993-1-11: 2006.
This National Annex gives:
(a) Nationally determined parameters for the following clauses of CYS EN 1993-1-11: 2006
where National choice is allowed (see Section NA 2):
• 2.3.6(1)
• 2.3.6(2)
• 2.4.1(1)
• 3.1(1)
• 4.4(2)
• 4.5(4)
• 5.2(3)
• 5.3(2)
• 6.2(2)
• 6.3.2(1)
• 6.3.4(1)
• 6.4.1(1)P
• 7.2(2)
• A.4.5.1(1)
• A.4.5.2(1)
• B(6)
(b) Decisions on the use of informative Annexes A, B and C to CYS EN 1993-1-11: 2006
(see Section NA 3).
(c) References to non-contradictory complementary information to assist the user to apply
CYS EN 1993-1-11: 2006 (see Section NA 4).
Table 2.2 (CYS): Stress limits f const for the construction phase
Stage of installation f const.
First tension components for only a few hours 0,60 σ uk
After installment of other tension components 0,55 σ uk
The stress limit f SLS = 0,45 σ uk is used for testing, see Annex A of CYS EN 1993-1-11: 2006.
NA 3.2 Annex B
Informative Annex B may be used.
NA 3.3 Annex C
Informative Annex C may be used.