Professional Documents
Culture Documents
TSH Ip 53.0067 - 01
TSH Ip 53.0067 - 01
TSH Ip 53.0067 - 01
Inspection Procedure
This document as well as the information or data contained herein are confidential and shall not be copied, recopied,
reproduced, transmitted, disclosed or distributed to others or otherwise used for any purpose without the express, prior
and written permission of Tenaris Connections AG and/or Hydril Company and/or its affiliated companies ("Tenaris").
This document as well as the information or data contained herein are the exclusive property of Tenaris, and are to be
returned upon request therefore. All rights in proprietary and novel features of the subject matter are expressly reserved
by Tenaris. Recipient’s agreement to the foregoing is indicated by acceptance of this document. Copyrighted 2008 as an
unpublished work. ALL RIGHTS RESERVED.
For PVD Qualification Document Type Inspection Procedure
Document Number TSH-IP-53.0067
Clip Thread Diameter Inspection
Wedge Box Threads Revision 01
Page Number 2
1. REVISION HISTORY
Effective
Rev. # Change Referenced Sections Prepared By: Reviewed by: Approved By:
Date
Document Change
Disposition of
Affected Material
Raw Material X
In Process X
Completed X
For PVD Qualification Document Type Inspection Procedure
Document Number TSH-IP-53.0067
Clip Thread Diameter Inspection
Wedge Box Threads Revision 01
Page Number 3
2. PURPOSE
2.1 The Purpose of this document is to explain the measurement of the BoxThread Clip Thread
Diameter.
3. PERSONS AFFECTED
4. REFERENCES
5.1 Definitions and Abbreviations are defined in the most current revision of TenarisHydril document
TSH-GP-00.0001.
6. RESPONSIBILITIES
6.1 Responsibilities are defined in the most current revision of TenarisHydril document
TSH-GP-00.0002.
7. PERSONNEL QUALIFICATION
7.1 Personnel qualification is defined in the most current revision of TenarisHydril document
TSH-GP-00.0003.
8. PROCEDURES
8.1 Inspection
The starting thread of some Wedge thread boxes has been truncated or clipped to reduce
the tapered thread crest to a cylindrical diameter. The axial length or degrees of clip
thread diameter is controlled by the clip thread start and the full form thread start.
Also see TSH-IP-53.0079.
Locate the clipped thread start ( end of higbee), locate the clip thread end (start of full form
thread ramp). Measure from thread crest to Thread crest after the clipped thread start and
before the clipped thread end. Typically this length will be either 45 degrees or 90 degrees
from the clip start.
For PVD Qualification Document Type Inspection Procedure
Document Number TSH-IP-53.0067
Clip Thread Diameter Inspection
Wedge Box Threads Revision 01
Page Number 4
Clip Thread Diameter Inspection is acceptable if the measured values are within the limits
prescribed on the IR.
8.3 Records
9. ANNEX