Professional Documents
Culture Documents
Falken Porsche Paper Model
Falken Porsche Paper Model
Falken Porsche Paper Model
1. Carefully cut out the model along the edges and fold all the grooved lines. The fold below the side
windows must be folded upwards
2. Rear: Insert tabs 1a into slots 1 (a), then tabs b, c and d mesh with each other and finally snap the tabs
into the slots 1 (e).
3. Rear: The tabs f, g, h, i and j mesh and the 1k tab into the 1 (k) slot snap into place.
The rear is now closed (Fig. 1).
4. Front: Insert tabs I into each other and then close the bow at the bottom.
5. Front: Insert the tabs m, o, p and q into the slots (m) to (q). The tab n will be pushed under the body.
The body is now closed (Fig. 2)
Image 1: The rear is closed.
6. Spoiler: Insert the r tabs into the slots and fold the carriers up. Fold the component so that the vertical
Image 3: The spoiler is inserted.
fins are created and the beams with the Tabs s lie against each other on the back. Finally insert the
spoiler in the body. (Fig. 3). Congratulations: the model is ready.