4:38 CHAPTER 4 Structural Concrete:
continuous beams and one-way slabs. satisfying (a)
through ():
a. Members are prismatic;
Loads are uniformly distributed:
ce bs 3D;
4d. There ae atleast to spans;
ce. The longer of two adjacent spans does not exceed
the shorter by more than 20 percent.
4065.2 My due to gravity Toads shall be calculated in
‘accordance with Table 406.5.2
‘Table 406.5.2 Approximate Moments for Non-
Prestressed Continuous Beams and One-Way Slabs
Moment [Loe Condition 7H,
Discontinuous end
sinters with wuld
End spon | Suppor
Positive Discontinuous end
unrestrained wnt
Trterior Z
spans al wilh /16
‘Member ball
fray wih | oq
Interior face | supporting
ofenterion | speckel beam
sw ea
Some [nar
mean
of first omen wth
mee fieetare [asso
Negative!
‘Other All wth / TL
in
Dui
eae
tava | Sra
Seow |actan
satisfying, Column tiffesses | Wot/12
Sect | seman
Senta
wet
(1 To caleuateneyaive moments, fy stall be the average of
the adjacent clear span lengths.
4065.3 It Moments calculated in accordance with
Section 406.5.2 shall not be redistributed.
4065.4 V,, due to gravity loads shall be calculated in
accordance with Table 406.5.4.
‘Table 406.5.4 Approximate Shears for
Non-Prestressed Continuous Beams and One-Way
Slabs
Location Ve
Entrior face of fret interior
LAS wyl/2
‘support v
Face ofall other supports wal/2
406.5.5 Floor or roof level moments shall be resisted
by distributing the moment between columns immediately
above and below the given floor in proportion to the
relative column stiffnesses considering conditions of
restraint.
406.6 First-order Analysis
406.6.1 General
406.6.1.1 Slendemess effects shall be considered in
accordance with Section 406.6.4, unless they are allowed
to be neglected by Section 406.2.5.
406.6.1.2_ Redistribution of moments calculated by an
elastic first-order analysis shall be permitted in
accordance with Section 406.6.5.
406.62 Modeling of Members and Structural
Systems
406.6.2.1 Floor or roof level moments shall be resisted,
by distributing the moment between columns immediately
above and below the given floor in proportion to
the relative column stiffnesses and considering conditions
of restraint.
406.6.2.2 For frames or continuous construction,
‘consideration shall be given to the effect of floor and roof
load patterns on transfer of moment to exterior and
interior columns, and of eccentric loading due to other
‘causes.
406.6.2.3 It shall be permitted to simplify the analysis
‘mode! by the assumptions of (a), (b), or both:
Solid slabs or one-way joist systems built integrally
with supports, with clear spans not mote than 3m.,
shall be permitted to be analyzed as continuous
‘members on knife edge supports with spans equal to
the clear spans of the member and width of support
beams otherwise neglected;
b, For frames or continuous construction, it shall be
permitted to assume the intersecting member regions.
are rigid
‘Association of Structural Engineers of the Philippines, Inc. (ASEP)