Professional Documents
Culture Documents
Manual - SV03 - SV03 999 73 011
Manual - SV03 - SV03 999 73 011
10. Press F6(STOP) -> Press F7(EDIT) -> F2( LADDER) -> Move cursor LEVEL1 (Hi speed area) or
LEVEL2(Normal area)
-> F5 (ZOOM) -> You will see PMC LADDER EDIT MENU screen
11. Edit ladder
To Search: Press F10(COMAND) -> Press F5 (Search) -> Input coil number -> Press F4(W-SRCH) ->
Press OPER/MAINTE return to PMC LADDER EDIT MENU screen
To add blank line: Move the cursor to the blank on upper line which wants to be added ->
Press F10(COMAND) -> Press F1 (INSNET) ->
The blank under the chosen line can be done ->
Press OPER/MAINTE return to PMC LADDER EDIT MENU screen
To add blank line: Move the cursor to the blank on upper line which wants to be added ->
(in circuit)
Press F10 (COMAND) -> Press F3(INSERT) -> Press F2 (INSLIN) ->
The blank under the chosen line can be done ->
Press OPER/MAINTE return to PMC LADDER EDIT MENU screen
To add blank area: Move the cursor to the blank on line which wants to be added ->
(in circuit)
Press F10(COMAND) -> Press F3 (INSERT) -> Press F3(INSELM) ->
The blank the chosen position can be done ->
Press OPER/MAINTE return to PMC LADDER EDIT MENU screen
To delete line : Move the cursor on line which wants to be deleted ->
Press F10(COMAND) -> Press F2 (DELNET) -> Press F1(EXEC)
Press OPER/MAINTE return to PMC LADDER EDIT MENU screen
11. Completed ladder edit-> PMC-RA5 : Press OPER/MAINTE -> Screen show WRITE DATA TO F-ROM? -> Go
to 14.
-> PMC-RB5 : Press OPER/MAINTE 2 times ->You will see PMC CONTROL SYSTEM MENU screen
-> PMC-RB6 : Press OPER/MAINTE 2 times -> Screen show WRITE DATA TO F-ROM? -> Go to 14.
12. Press F8(I/O) -> You will see PMC I/O PROGRAM screen
13. Set DEVICE = F-ROM (Select by Function key)
FUNCTION = WRITE
DATA KIND = LADDER
14. Press F1(EXEC) -> It will take a couple of second. Screen show COMPLETE
15. Press OPER/MAINTE -> Press F6(RUN) -> PC changed RUN
16. Press F3(PMCPRM) -> Press F5(SETING)
17. Change PROGRAMMER ENABLE = 0 (NO)
18. Press ALTER -> Select 3. F_SETTING -> Press INPUT
19. Change PARAMETER WRITE = 0 (DISABLE)
20. Press ALTER
21. NC power off -> Take out LADDER EDIT card from FANUC CRT -> NC power on
22. Check the edited ladder