8.1.4-NR Mux-2m

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 2

COMMUNICATIONS

MUX-2M/MUX-64
Interface Unit

MUX-2M and MUX-64 relay digital signal interface units are MUX-2M and MUX-64 can be installed in communication rooms
communication interfaces between RCS-900 series current near digital multiplexer communication devices. It connects with
differential protection relays, RCS-900 series permissive the multiplexer communication device via 75Ω or 120Ω coaxial
teleprotection relays, and RCS-900 series power system cable and connects with a protection relay by optical fiber.
stability control relays. Connections between MUX and relays
are implemented by optical fibers. MUX-2M and MUX-64 also
can be connected to multiplexers through electrical interface
with 2048kbit/s or 64kbit/s bit rate.

Technical data
Power Supply
Auxiliary Voltage -48V DC (0V grounded)
Operating Range -32VDC~63VDC
Nominal Burden 10W

Interface Specifications
Device MUX-64 MUX-2MC

Bit rate 256 kBauds 2048kbit/s ± 50ppm


Pair(s) in each direction One symmetric pair One coaxial pair
Test load impedance 120 ohms resistiv 75 ohms resistive
Nominal peak voltage of a mark (pulse) 1.0 V 2.37 V
Peak voltage of a space (no pulse) 0 V ± 0.10 V 0 ± 0.237 V
Nominal pulse width 3.9 us 244 ns
Ratio of the amplitudes of positive and negative
0.95 to 1.05 0.95 to 1.05
pulses at the centre of the pulse interval
Ratio of the widths of positive and negative
0.95 to 1.05 0.95 to 1.05
pulses at the nominal half amplitude
Maximum peak-to-peak jitter at an output port Refer to 5.1/G.823
Coaxial connector (female,L9) 1.5/5.6 Straight Jack For PCB, Female
Coaxial connector (male,L9) 1.5/5.6 Right Angle Plug Crimp, Male
Coaxial cable SYV-75-2
Transmission distance twisted wire<50m (between MUX-64 to Coaxial cable<50m; fiber cable≤30Km
PCM);
fiber cable≤30Km (between relay to MUX-
64)

Read more on the web


380 read more on www.nrelect.com www.nrelect.com
Optical-fiber Connector Specifications
Optical-fiber connector FC-PC connector
Transmission medium 9/125µm single mode fiber cable
Emission power -15.0±2.0dBm
Receiving sensitivity -33.0±2.0dBm
Recommended light-transfer distance ≤30Km
Recommended electrical-transfer distance ≤20m

Mechanical Specifications
Dimensions 482.6 mm (W) x 44.4 mm (H) x 229mm (G)
Enclosure Protection Per IEC60259:2001
IP40 for front panel

Read more on the web


www.nrelect.com read more on www.nrelect.com 381

You might also like